Instructions for UseOriginal Instructions6/11 revised 8/2013 REV AFORM NO. 56041980Models: 56509003(LPG), 56509004(Diesel), 56509005(Battery)56511002(Petrol)CS7000INSTRUCTIONS FOR USE

Nilfisk-Advance CS7010 Instructions For Use Manual

service manual

General Information

Other Reference Manuals and Information Sources

Engine Manufacturers' Technical Manuals

Cautions and Warning Symbols

Hopper Prop Rod

Jacking the Machine

Towing the Machine

Diagnostic and Service Tools

Technical Specifications

Fastener Torque Specifications

Overall Dimensions

Maintenance

Maintenance Every 15 to 20 Hours

Maintenance Every 800 to 1000 Hours

Lubrication Points

EcoFlex System Maintenance

To Change the Detergent Mix Ratio (the scrub system must be on)

PM Checklist

Machine Controls

Miscellaneous Indicators

Scrub Controls

Scrub Indicators

Sweep Indicators

Hopper Controls

Diesel Machine

Fault, Caution and Warning Displays

Warning Displays

Steering Wheel

Chassis System

Component Locations - LPG and Diesel Machine (major components)

Control System

CAN Bus Circuit

CAN BUS message routing

Steering Controller

Component Locations

Troubleshooting

Fault Code Table (Main machine controller)

Hidden Menus

Configuration Menu

User Options Menu

Service Mode

To Operate

Control Panel LEDs all stay lit - CAN Bus problems

Removal and Installation

Control Panel

Specifications

J3 Connector (Gray)

J7 Connector (Black)

Dust Control/DustGuard™ Systems

DustGuard™ Spray System (optional)

DustGuard™ System Wiring Diagram

Circuit Description

Dust Control Filter Switch

DustGuard™ Spray System

Maintenance and Adjustments

To Clean the Dust Control Filter

To Clean the DustGuard™ Strainer Screen

To Clean the DustGuard™ Spray Nozzles

To Remove and Reinstall the DustGuard™ Pump

To Remove and Reinstall the Dust Control Filter Switch

To Disassemble and Reassemble the Impeller Assembly

Electrical System

Wiring Harnesses

Circuit Protection

Low Voltage Cutout

Headlights

Electrical Panel Contactor/Relay location

Harness to Harness Connector Locations

Connector Pin-Outs

Wiring Connections

Late style K14 Safety Relay and K15 Auxiliary Relay

volt Generator

Head Light bulb - Standard 12v Halogen

Current Sensors

Wiring Diagrams

LEV Engine Side Wiring 56511576_REV_A_LEV_ENG sheet 1 of 1

Engine System - LPG

Circuit Descriptions

Engine Starter Control

Throttle Control Modes

56509003

56509004

56509005

56511002

CS7010