Quantel EverGreen2 Quick Setup Manual
  |
Page 1 of 2Coolant-levelwindowQUICK SETUP GUIDEEverGreen 2 Part Numbers: EVG00070, EVG00145, EVG00200Version A | # DOC00140 | February 28, 2020Read the User Manual.Connect the USB memory device to a computersystem and read the User Manual.1234Connect the AC Mains Power.• Connect the AC Mains power cord to 100-240 VAC,50/60 Hz power.• Turn on the AC Mains power switch.• Turn on the Key Switch located on the ICE frontpanel.2 . 5 L i t e r sD i s t i l l e d H 2 0You will need2.5 liters ofdistilled water.© 2020Prime the Cooling System.CAUTION: DO NOT power on the systemunless the coolant is filled and the pump isprimed or pump damage will result.• Remove the drain tube from its storage locationon the ICE rear panel. Connect it between theICE rear panel ports to form a loop.• Remove the cap and fill the reservoir with theapproved coolant.Coolant tubeloopDrain tubestoragelocationConnectAC Mainspower cordTurn on ACMains powerswitchPrime the Coolant Pump.Press the green Pump Cntrl button located on theICE rear panel to operate the pump and circulate thecoolant for about 2 seconds. Listen for the sound ofthe pump operating smoothly. Press and hold thePump Cntrl button to circulate coolant for severalseconds if and only if pump operation is smooth.CAUTION: Do not operate the pump if it is making a“buzzing” or “clattering” sound. This indicates nocoolant in the pump. If this happens, tip the ICEtoward the rear panel to lower the coolant loopbefore testing coolant circulation again.Press Pump Cntrl brieflyto test coolant circulation5 Connect the Laser Head.CAUTION: Turn the Key Switch OFF.Turn the AC Mains power switch OFF.• Simultaneously disconnect both ends of the draintube from the ICE rear panel.• Connect the I/O cable between the ICE and theLaser Head. Rotate the connector to fully tighten it.• Connect the 2 coolant tubes between the LaserHead and the ICE. Match the connectors: blue toblue and red to red.CAUTION: Do NOT operate the flashlampsuntil all trapped air is removed from the cool-ant tubes and Laser Head, or Laser Headdamage will result.PumpCntrlbuttonContinue to page 2.2KeySwitchlocationICE FRONT PANEL |
Related manuals for Quantel EverGreen2
This manual is suitable for:
manualsdatabase
Your AI-powered manual search engine