Carrier 58UVB Series Installation, Start-up, And Operating Instructions Manual

Also see for 58UVB series: Owner's information manual Owner's manual Installation, start-up, and operating instructions

Carrier 58UVB Series Installation, Start-up, And Operating Instructions Manual Manual pdf 1 page image

rn to the Expertg]Installation, Start-Up, andOperating Instruct,onsNOTE: Read the entire instruction manual before starting theinstallation.TABLE OF CONTENTSPAGESAFETY CONSIDERATIONS ........................ 2DIMENSIONAL DRAWING .......................... 3Clearances to Combustibles ........................ 4CODES AND STANDARDS .......................... 5ELECTROSTATIC DISCHARGE (ESD) PRECAUTIONS . . 6INTRODUCTION .................................. 6APPLICATIONS ................................... 6General ........................................ 6Applications ..................................... 6LOCATION ....................................... 8General ........................................ 8Low-Heat Only Installation ........................ 10Location Relative to Cooling Equipment .............. 10Hazardous Locations ............................. 10INSTALLATION .................................. 10Leveling Legs (If Desired) ......................... 10Air Ducts ....................................... 11Filter Arrangement ............................... 11Bottom Closure Panel ............................. 12Gas Piping ..................................... 12Electrical Connections ............................ 14Removal of Existing Furnaces from Common Vent Systems 17Combustion-air and Vent Pipe Systems ............... 18Condensate Drain ................................ 32START-UP, ADJUSTMENTS. AND SAFETY CHECK . . . 33General ........................................ 33AIRFLOWC>UPFLOW_Fig. 1 - Furnace OrientationA06340NNIAs an ENERGY STAR(s) Partner,Carrier Corporation has deter-mined that this product meetsthe ENERGY STAR@ guidelinesfor energy efficiencyCERTIFIEDISO 9001:2000@Select Setup Switch Positions ....................... 33Prime Condensate Trap with Water ................... 34Purge Gas Lines ................................. 35Sequence of Operation ............................ 35Adjustments .................................... 43Check Safety Controls ............................ 48CHECKLIST ..................................... 49