Carrier 58UVB series Installation, Start-up, And Operating Instructions Manual

Also see for 58UVB series: Owner's information manual Owner's manual Installation, start-up, and operating instructions

Contents

Carrier 58UVB series Installation, Start-up, And Operating Instructions Manual Manual pdf 1 page image

58UVBDirect---Vent UpflowVariable---Capacity Condensing Gas FurnaceFor Sizes 060---120, Series 100Installation, Start---Up, andOperating InstructionsNOTE: Read the entire instruction manual before starting theinstallation.TABLE OF CONTENTSPAGESAFETY CONSIDERATIONS 2. . . . . . . . . . . . . . . . . . . . . . . .DIMENSIONAL DRAWING 3. . . . . . . . . . . . . . . . . . . . . . . . . .Clearances to Combustibles 4. . . . . . . . . . . . . . . . . . . . . . . .CODES AND STANDARDS 5. . . . . . . . . . . . . . . . . . . . . . . . . .ELECTROSTATIC DISCHARGE (ESD) PRECAUTIONS 6. .INTRODUCTION 6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .APPLICATIONS 6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .General 6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Applications 6. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .LOCATION 8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .General 8. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Low--Heat Only Installation 10. . . . . . . . . . . . . . . . . . . . . . . .Location Relative to Cooling Equipment 10. . . . . . . . . . . . . .Hazardous Locations 10. . . . . . . . . . . . . . . . . . . . . . . . . . . . .INSTALLATION 10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Leveling Legs (If Desired) 10. . . . . . . . . . . . . . . . . . . . . . . . .Air Ducts 11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Filter Arrangement 11. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Bottom Closure Panel 12. . . . . . . . . . . . . . . . . . . . . . . . . . . . .Gas Piping 12. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Electrical Connections 14. . . . . . . . . . . . . . . . . . . . . . . . . . . .Removal of Existing Furnaces from Common Vent Systems 17Combustion--air and Vent Pipe Systems 18. . . . . . . . . . . . . . .Condensate Drain 32. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .START--UP, ADJUSTMENTS, AND SAFETY CHECK 33. . .General 33. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .UPFLOWAIRFLOWA06340Fig. 1 --- Furnace Orientationama CERTIFIEDAs an ENERGY STAR® Partner,Carrier Corporation has deter-mined that this product meetsthe ENERGY STAR® guidelinesfor energy efficiency.REGISTEREDISO 9001:2000Select Setup Switch Positions 33. . . . . . . . . . . . . . . . . . . . . . .Prime Condensate Trap with Water 34. . . . . . . . . . . . . . . . . . .Purge Gas Lines 35. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Sequence of Operation 35. . . . . . . . . . . . . . . . . . . . . . . . . . . .Adjustments 43. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Check Safety Controls 48. . . . . . . . . . . . . . . . . . . . . . . . . . . .CHECKLIST 49. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .