Catalina A10-1218 Gourmet Series Owner's Manual
          | |
USING GRILL WITH ON-BOARD CNG (NATURAL GAS) SYSTEMSMagma's grills are designed for use with small disposable propane canisters or with pre-regulatedlow-pressure propane and optional low-pressure valves. Running high-pressure propane fuel supplylines on a boat is in violation of American Boat & Yacht Council (ABYC) guidelines and is notconsidered a safe application. Additionally, impurities found in larger refillable propane tanks mayclog the small orifices in the high-pressure control valve/ regulator causing it to lose performancecapabilities and eventually fail. Regulating these tanks to 1/2 PSI and using this pre-regulatedpropane with the correct low-pressure valve will insure safe, efficient performance of the grill.Problem Possible CauseElectrode covered with grease or residueIgniter/electrode too far from burnerElectrode wire loose,disconnected, or corrodedWire is shorted causing spark from wirebefore electrodeNo spark being generatedNo gas flowObstructed gas flowExcessive cooking temperatureGrease and/or residue build-upExcessive fat in meatsExcessive oils in marinadesObstructed gas flowFlame too lowWind directly on burnerObstructed gas flowGrill not levelGrease or residue build-upExcessive fat in meatsExcessive oil in marinadesPossible SolutionClean electrodeAdjust electrode until proper sparkappears (see page 5)Clean, adjust & reconnect wire betweenigniter & electrode, see CompleteDisassembly (page 5)Replace Igniter, Electrode & Wire.See website for part numberReplace Igniter, Electrode & Wire.See website for part numberCheck fuel level, replace canister orrefill cylinderClean burner and valve orifice.Remove debris/spider websOperate only on low when lid is closedReduce flame levelLeave lid openUse water spray to coolClean componentsTrim fat from cuts of meat before grillingUse non-oil based marinadesClean burner and valve orifice.Remove debris/spider websIncrease flameBlock wind when opening lidClean burner and valve orifice.Remove debris/spider websLevel GrillClean componentsTrim fat from cuts of meat before grillingUse non-oil based marinadesIMPORTANT!! • DO NOT CONNECT A HIGH-PRESSURE SUPPLY HOSEFROM A NON-REGULATED TANK DIRECTLY TO GRILL.Hot SpotsBlow-outYellow sootyflameFlare-upBurner willnot lighteven withmatchBurner willnot lightwith igniter• Magma on-board CNG (natural gas) valves allow Magma grills to be installed to an existing on-board,pre-regulated low pressure CNG (natural gas) system.• Use only Magma Type 4 Low Pressure CNG (natural gas) control valves. Visit out website atwww.MagmaProducts.com to view valve application guide. See your local dealer for proper hose and fittings.TROUBLE SHOOTING GUIDE |
This manual is suitable for:
manualsdatabase
Your AI-powered manual search engine