Genie IntelliG 1000 3024 Manual

Also see for 3024: Programming, operation & maintenance manual Maintenance manual Product guide

Contents

Genie IntelliG 1000 3024 Manual Manual pdf 17 page image

©2010 The Genie Company 01/27/2010 17MAINTENANCE & TROUBLESHOOTING FOR HELP-1.800.354.3643 OR WWW.GENIECOMPANY.COM6WARNING• Garage door hardware (springs, cables, brackets,pulleys, etc.) are under extreme pressure andtension.• DO NOT attempt to repair or adjust doorsprings or any hardware, and DO NOT OPERATEgarage door automatically or manually if dooris improperly balanced or springs are broken.– CONTACT A TRAINED DOOR SYSTEMTECHNICIAN.ROUTINE MONTHLY MAINTENANCEBasic monthly maintenance tasks.• Door balance• Safe-T-Beam® System Check• Contact reverseInstructions for these tasks and others are found onthe following pages.DOOR BALANCE (SPRING TENSION)• With the door closed, pull release handleDOWN and let go to release door carriageassembly from drive system.• Raise door manually approximately 3’- 4’ andrelease.– Door should remain stationary or move veryslightly.– If door moves quickly, CONTACT A TRAINEDDOOR SYSTEM TECHNICIAN.• Close the door.• Pull emergency release handle DOWN and let goto engage carriage assembly to drive system.– Operate door using remote or wall console.– Door will re-attach itself to carriage assembly.If you have any questions, please do not hesitate to contact customer service at: 1.800.354.36433’ - 4’Sectional Door3’ - 4’One-Piece DoorFIG. 6-1 Door balanceWARNINGUse wall console supplied with opener. Anyother wall console can cause the opener tooperate unexpectedly.Safe-T-Beam® (STB) SYSTEM CHECK• STB Red and Green LEDs ON steady, system OK• STB Red LED flashes– Check for obstruction– Check alignment– Verify wire routing from STBsto STB connection in powerhead– Check for signal interferencefrom another Safe-T-Beam®unit• No STB Red or Green LED displayed– Check wiring and wire connectionsSTB BWC IWCNOTUSED NOTUSEDNOTUSED NOTUSEDFROM STBsFROM WALLCONSOLEIMPORTANT SAFETY INSTRUCTIONSWARNING:To reduce the risk of severe injury or death:1. READ AND FOLLOW ALL INSTRUCTIONS.2. Never let children operate or play with the door controls. Keep the remote away from children.3. Always keep the moving door in sight and away from people and objects until the door is completely closed. NOONE SHOULD CROSS THE PATH OF THE MOVING DOOR.4. NEVER GO UNDER A STOPPED, PARTIALLY OPEN DOOR.5. Test opener monthly. The door MUST reverse on contact with a 1-1/2" high object (or a 2" x 4" board laid flat)at the center of the doorway on the floor. After adjusting either the force or the limit of travel, retest the dooropener. Failure to adjust the opener properly may cause severe injury or death.6. When possible, use the emergency release only when the door is closed. Use caution when using this releasewith the door open. Weak or broken springs are capable of increasing the rate of door closure and increasing therisk of severe injury or death.7. KEEP DOORS PROPERLY BALANCED. See your garage door Owner’s Manual. An improperly balanced doorincreases the risk of severe injury or death. Have a trained door system technician make repairs to cables, springassemblies, and other hardware.8. SAVE THESE INSTRUCTIONS.