Kalamazoo Outdoor Gourmet K500HB Use And Care Manual

Kalamazoo Outdoor Gourmet K500HB Use And Care Manual Manual pdf 15 page image

1.800.868.169911Natural Gas RequirementsVerify the type of gas your grill has been configured for by the factory bychecking the serial tag inside the door of the grill cabinet. Grills configured fornatural gas (NG) are orificed differently than grills configured for liquid propane(LP) gas. Grills configured for use with natural gas are shipped with a gray hosewith a quick-connect fitting.Connection: Quick-connect hose assembly (included) connects to the grill via0.5" NPT male with a 0.375" flare adapter (included).Input Pressure: 7.0" W.C.Operating Pressure: 7.0" W.C. (cooktop burners) and 3.5" W.C. (all otherburners via additional regulator installed inside grill).IMPORTANT: Always close gas supply shut-off valve before disconnecting the grill gas supply hose.IMPORTANT: An installer-supplied safety shut-off valve MUST be installed on the natural gas supply line for thegrill. The valve should be easily accessed and located between 3 and 20 feet away from the grill.All gas connections should be made by a qualifiedtechnician. The installation and all installer-suppliedparts must conform to local codes. In the absenceof local codes, the installation and all parts shouldconform to the National Fuel Gas Code, ANSI Z223.1/NFPA 54 or Natural Gas and Propane Installation Code,CSA B149.1.All pipe sealants must be an approved type.Grill BTUs: See serial tag.IMPORTANT: Diameter and length of the gas supplypipe may limit the pressure and BTU delivery of gas tothe grill. The installer must ensure proper delivery tothe grill or it will not operate properly.The appliance and its individual shut-off valve must bedisconnected from the gas supply piping system duringany pressure testing of that system at pressures inexcess of 1/2 psi (3.5 kPa).During any pressure testing of the gas supply pipingsystem at test pressures equal to or less than 1/2 psi(3.5 kPa), the appliance must be isolated from thesystem by closing its individual manual shut-off valve. Installer Supplied Shut-off ValveMust be Easily AccessibleFactory-supplied1/2" Gas HoseRegulator 3.5" WCFIGURE 4