Malibu Boats Response Owner's Manual

Also see for 2008 iRide: Owner's manual

Malibu Boats Response Owner's Manual Manual pdf 89 page image

Engine/Drive TrainEngineFor information on engine service, maintenance and break-in period, please refer to yourengine owner’s manual. The Required Maintenance Schedule included in this manual coversthe minimum maintenance required for Indmar engine packages. The MaintenanceWorksheet included in this manual outlines safety checks, lubrication and general servicethat should be performed at regular intervals. It is recommended that any engine replacementparts used for maintenance or repair be supplied by an authorized Malibu dealer.Engine SpecificationsNotes1) Minimum recorded compression in any one cylinder should not be less than 70% of the highest recorded cylinder.2) Measured using an accurate shop tachometer at normal operating temperature. Idle RPM on EFI models is not adjustable.3) Timing must be set using special procedures indicated in the appropriate service manual. Timing cannot be set usingconventional methods. Special tool(s) required.4) Always use dipstick to determine exact quantity of oil required. Do not fill above “FULL” mark.5) Do not over fill. Correct level is at the “Full Cold” mark on the coolant recovery bottle when coolant is cold.IPML1.86YL/3SL/2SL7SL)383(L2.6IPML7.5deterubraCL7.5sledoMenignENumber of Cylinders)L1.8(DIC694)L0.6(DIC463)L0.7(DIC724)L3.6(DIC383tnemecalpsiDBore/Stroke 4.0012 x 3.8 in.( 101.63 x 96.52 mm)4.125 x 4.00 in.(104.8 x 101.6 mm)3.898 x 3.622 in.(99 x 92 mm)4.25 x 4.37 in.(108 x 111 mm)1:1.91:1.011:0.111:7.9oitaRnoisserpmoCCompression Pressure (Note 1)Idle RPM in Neutral (Note 2)Operating Range at WOT 4400-4800 RPM 5000-5400 RPMOil Pressure at Idle 5 PSI (34 kPa) MinimumOil Pressure at 2000 RPM 10 PSI (69 kPa) MinimumFuel Pump Pressure 8 PSI Maximum (55.2 kPa)Electrical SystemMinimum Battery RequirementsFiring OrderSpark Plug Type AC 41-983)mm67.(.ni030.paGgulPkrapSBase Timing at 1000 RPM (Note 3) 10° BTDCThermostatCrankcase (With Filter) (Note 4) 10 Quarts (9.5L)Closed Cooling Systen (Note 5) 14-16 Quarts (13.2-15.1L)In-Line 1:1 Transmission (Note 4) 4.2 Quarts (4L) 15W40In-Line Reduction Gear (Note 4) 4.2 Quarts (4L) 15W40ZF Ski Vee Transmission (Note 4)ZF V-Drive Transmission (Note 4)Walter V-Drive2008 Malibu EnginesFluid CapacitiesV-8350 CID (5.7L)9.4:14.0012 x 3.480 in.(101.63 x 88.39 mm)Minimum 100 PSI (690 kPa)650 ± 50 RPMMPR0065-0025MPR0025-00644 PSI (41 kPa) Minimum Hot18 PSI (124 kPa) Minimum HotPennzoil PZ3, AC-PF25650 cca/700 mca/120AhAC-PF454 (on engine)Pennzoil PZ3 (remote)Oil Filter12 Volt DC Negative (-) Ground60 PSI Minimum at Keyup (414 kPa)3-4-5-6-2-7-8-12-7-5-6-3-4-8-1589-14CA399-14ro239-14CA)mm3.1(.ni040.)mm5.1(.ni060.Nonadjustable160°F (71°C)4.2 Quarts (4 L) Pennzoil 15W400.5 Quart (0.5 L) Pennzoil SAE 30 Motor Oil5.5 Quarts (5.25 L) with Filter12-14 Quarts (11.4-13.3 L)1.7 Quarts (1.6 L) Dexron 3 ATF2.12 Quarts (2 L) Pennzoil 15W402.12 qt (2 L) Main Gearbox, 1.0 qt (1.06 L) V-drive - Dexron 34-5