Malibu Boats Response Owner's Manual
                                                                                                                                    | |
Contents
| 
4-6Engine SpecificationsNotes1) Minimum recorded compression in any one cylinder should not be less than 70% of the highest recorded cylinder.2) Measured using an accurate shop tachometer at normal operating temperature. Idle RPM on EFI models is not adjustable.3) Timing must be set using special procedures indicated in the appropriate service manual. Timing cannot be set usingconventional methods. Special tool(s) required.4) Always use dipstick to determine exact quantity of oil required. Do not fill above “FULL” mark.5) Do not over fill. Correct level is at the “Full Cold” mark on the coolant recovery bottle when coolant is cold.Engine Models 5.7L Carbureted 5.7L MPI 6.2L (383) LS7 LS2/LS3/LY6 8.1L MPINumber of Cylinders V-82009 Malibu EnginesFluid CapacitiesDisplacement 350 CID (5.7L) 383 CID (6.3L) 427 CID (7.0L) 364 CID (6.0L) 496 CID (8.1L)Crankcase (with Filter)4 5.5 Quarts (5.25L) with Filter 10 Quarts (9.5L)ZF Ski Vee Transmission4 2.12 Quarts (2L) Main Gearbox, 1.0 Quarts (1.06L) V-drive – Dexron 3ZF V-Drive Transmission4 4.2 Quarts (4L) Pennzoil 15W40Walter V-Drive 0.5 Quart (0.5L) Pennzoil SAE 30 Motor OilIn-Line 1:1 Transmission4 1.7 Quarts (1.6L) Dexron 3 ATF 4.2 Quarts (4L) 15W40In-Line Reduction Gear4 2.12 Quarts (2L) Pennzoil 15W40 4.2 Quarts (4L) 15W4014-16 Quarts(13.2-15.1L)Closed Cooling System5 12-14 Quarts (11.4-13.3L)Spark Plug Gap .030 in. (.76 mm) .060 in. (1.5 mm) .040 in. (1.3 mm)Base Timing at 1000 RPM3 10° BTDC NonadjustableThermostat 160°F (71°C)Firing Order 1-8-4-3-6-5-7-2 1-8-7-2-6-5-4-3Spark Plug Type AC 41-932 or 41-993 AC 41-985 AC 41-983Electrical System 12 Volt DC Negative (-) GroundMin. Battery Requirements 650 cca/700 mca/120 Ah8 PSI Maximum(55.2 kPa) 60 PSI Minimum at Keyup (414 kPa)Operating Range at WOT 4400-4800 RPM 4600-5200 RPM 5200-5600 RPM 5000-5400 RPMOil Pressure at Idle 4 PSI (41 kPa) Minimum Hot 5 PSI (34 kPa) Min.Oil Pressure at 2000 RPM 18 PSI (124 kPa) Minimum Hot 10 PSI (69 kPa) Min.AC-PF454 (on engine)Pennzoil PZ3 (remote)Idle RPM in Neutral2 650 ± 50 RPMCompression Ratio 9.4:1 9.7:1 11.0:1 10.1:1 9.1:1Compression Pressure1 Minimum 100 PSI (690 kPa)4.0012 x 3.480 in. 4.0012 x 3.8 in. 4.125 x 4.00 in. 3.898 x 3.622 in. 4.25 x 4.37 in.(101.63 x 88.39 mm) (101.63 x 96.52 mm) (104.8 x 101.6 mm) (99 x 92 mm) (108 x 111 mm)Oil Filter Pennzoil PZ3, AC-PF25Bore/StrokeFuel Pump Pressure |
Related manuals for Malibu Boats 2009 21 vRide
Malibu Boats Response Owner's Manual
Malibu Boats Response Owner's Manual
Malibu Boats Response LX Owner's Manual
Malibu Boats Response TXi Owner's Manual
Malibu Boats Response TXi Owner's Manual
Malibu Boats RESPONSE TXi 2021 Owner's Manual
Malibu Boats 1982 Owner's Manual
Malibu Boats 2000 Owner's Manual
Malibu Boats 1997 Owner's Manual
Malibu Boats Boat 2014 Owner's Manual
This manual is suitable for:
2009 21 vRide2009 23 vRide2009 Response2009 Response FXi2009 Response LXi2009 Response XL2009 Sunscape 20 LSV2009 Sunscape 23 LSV2009 Sunscape 247 LSV2009 Wakesetter VLX2009 Wakesetter VTX21 vRide23 vRideResponseResponse FXiResponse LXiResponse XLSunscape 20 LSVSunscape 21 LSVSunscape 23 LSVSunscape 247 LSVWakesetter 23 LSVWakesetter 23 XTiWakesetter 247 LSVWakesetter 247 RXWakesetter VLXWakesetter VTX
manualsdatabase
Your AI-powered manual search engine