Napoleon GDS60-1N Installation And Operating Instructions Manual

Also see for GDS60-1N: Installation and operation manual Installation and operating instructions

Contents

Napoleon GDS60-1N Installation And Operating Instructions Manual Manual pdf 7 page image

7ENW415-1328 / A / 01.05.16When the appliance is installed at elevations above 4,500ft (1371m), and in the absence of specific recommendationsfrom the local authority having jurisdiction, the certified high altitude input rating shall be reduced at the rate of 4% foreach additional 1,000ft (305m).Change in flame appearance from "HI" to "LO" is more evident in natural gas than in propane.Expansion / contraction noises during heating up and cooling down cycles are normal and to be expected.This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertiblefor use with other gases, unless a certified kit is used.GDS60-1 - This appliance is not approved for closet or recessed installations. It is approved for bathroom,bedroom and bedsitting room installations. This appliance may be installed in an aftermarket permanentlylocated, manufactured (mobile) home, where not prohibited by local codes. (Rear vent) This applicationrequires changing the main burner orifice, for horizontal exits off the rear only.GS60-1 - This appliance is approved for bedroom and bed-sitting room installations.INSTALLER: It is your responsibility to check off the appropriate box on the rating plate according to themodel, venting and gas type of the unit.For rating plate location, see “INSTALLATION OVERVIEW” section.This illustration is for reference only. Refer to the rating plate on the appliance for accurate information.NOTE: The rating plate must remain with the appliance at all times. It must not be removed.A barrier designed to reduce the risk of burns from the hot viewing glass is provided with theappliance and shall be installed.2.4 RATING PLATE INFORMATION.GDS60-1WOLF STEEL LTD.24 NAPOLEON ROAD, BARRIE, ON, L4M 0G8 CANADA W385-1961CONFORMS TO / CONFORME AUX: ANSI Z21.50-2014, CERTIFIED TO / CERTIFIE CSA 2.22-2014VENTED GAS FIREPLACE / FOYER À GAZ VENTILÉ.MODEL NATURAL GAS/GAZ NATURAL MODEL PROPANE/PROPANE MODÈLEDIRECT VENT B-VENT B-VENT DIRECT VENTGDS60-1N GS60-1N GS60-1P GDS60-1PCDVS600-1N CS600-1N CS600-1P CDVS600-1PTOP VENT REAR VENT TOP VENT REAR VENT0-4500 0-4500 0-4500 ALTITUDE(FT/PT)ELEVATION 0-4500 0-4500 0-450035,000 *21,000 35,000 INPUT(BTU/H)ALIMENTATION 31,500 31,500 *21,00021,000 12,000 21,000 REDUCED INPUT(BTU/H)ALIMENTATION REDUITE 22,000 22,000 *13,00024,500 *14,700 OUTPUT(BTU/H)RENDEMENT 22,050 *14,70063.1% P4 63.1%*WHEN VENTING OFF THE REAR OF THE UNIT AND TERMINATING HORIZONTALLYMANIFOLD PRESSURE: 3.5 INCHES W.C. (NG) / 10 INCHES W.C. (LP)PRESSION AU COLLECTEUR: 3.5” (GN) / 10” (PG) D’UNE COLONNE DEAUMIN SUPPLY PRESSURE: 4.5” W.C. (NG) / 11” (LP)PRESSION D’ALIMENTATION MIN: 4.5” (GN) / 11” (PG) D’UNE COLONNED’EAUMAX. SUPPLY PRESSURE: 7” W.C. (NG) / 13” W.C. (LP)PRESSION D’ALIMENTATION MAX: 7” (GN) / 13” (PG) D’UNE COLONNE D’EAUFOR USE WITH GLASS DOORS CERTIFIED WITH THIS UNIT ONLY.UTILISER AVEC LES PORTES VITREES HOMOLOGUEES SEULEMENT AVECCETTE UNITE.WARNING: DO NOT ADD ANY MATERIAL TO THE APPLIANCE, WHICH WILLCOME IN CONTACT WITH THE FLAMES, OTHER THAN THAT SUPPLIED BYTHE MANUFACTURER WITH THE APPLIANCE.DECORATIVE PRODUCT: NOT FOR USE AS A HEATING APPLIANCEOPTIONALBLOWER KIT / ENSEMBLE DEVENTILATEUR FACULTATIF: GS64-KTAVERTISSEMENT: N’AJOUTEZ PAS A CET APPAREIL AUCUNMATERIAU DEVANT ENTRER EN CONTACT AVEC LES FLAMMES AUTREQUE CELUI QUI EST FOURNI AVEC CET APPAREIL PAR LE FABRICANT.PRODUIT DÉCORATIF: NE PAS UTI;ISER COMME APPARIEL DECHAUFFAGEMINIMUM CLEARANCE TO COMBUSTIBLE MATERIAL / DEGAGEMENTSMINIMAUX DES MATERIAUX COMBUSTIBLES:A 6”B 6”C 2”20” TO CEILING FROM STOVE TOP1” TO DIRECT VENT AND B-VENT / L’EVACUATION DIRECTE &L’EVACUATION B6” TO C-VENT/ A L’EVACUATION C20” ENTRE LE DESSUS DU FOYER ET LE PLAFONDELECTRICAL RATING/CLASS: 115V 1.5AMP 60HZMODEL CS600-1/GS60-1APPROVED FOR BEDROOM, & BEDSITTING ROOM INSTALLATION. HOMOLOGUE POURINSTALLATION DANS UNE CHAMBRE A COUCHER, & UN STUDIO. THIS APPLIANCE MUSTBE INSTALLED USING AN ADAPTER KIT GS-150KT. CET APPAREIL DOIT ETRE INSTALLEEN UTILISANT UN ENSEMBLE ADAPTATEUR GS-150KT.MODEL CDVS600-1/GDS60-1 APPROVED FOR BEDROOM, BATHROOM & BEDSITTINGROOM INSTALLATION. SUITABLE FOR MOBILE HOME INSTALLATION IF INSTALLED INACCORDANCE WITH THE CURRENT STANDARD CAN/CSA Z240MH SERIES GAS EQUIPPEDMOBILE HOMES, IN CANADA OR IN THE UNITED STATES THE MANUFACTURED HOMECONTRUCTION AND SAFETY STANDARD, TITLE 24 CFR, PART 3280. WHEN THIS USSTANDARD IS NOT APPLICABLE USE THE STANDARD FOR FIRE SAFETY CRITERIA FORMANUFACTURED HOME INSTALLATIONS, SITES AND COMMUNITIES, ANSI/NFPA 501A. FORUSE WITH BARRIER W010-3296. FOLLOW THE INSTALLATION INSTRUCTIONS LOCATEDIN THE INSTALLATION MANUAL.HOMOLOGUE POUR INSTALLATION DANS UNE CHAMBRE A COUCHER, UNE SALLE DEBAIN ET UN STUDIO. APPROPRIE POUR INSTALLATION DANS UNE MAISON MOBILE SI SONINSTALLATION CONFORME AUX EXIGENCES DE LA NORME CAN/CSA Z240MH SERIE DEMAISONS MOBILES EQUIPEES AU GAZ, EN VIGUEUR AU CANADA OU AUX ETATS-UNIS DELA NORME DE SECURITE ET DE CONSTRUCTION DE MAISONS MANUFACTUREES, TITRE24 CFR, SECTION 3280. DANS LE CAS OU CETTE NORME D’ETATS-UNIS NE PEUT ETREAPPLIQUEE, SE REFERER A LA NORME RELATIVE AU CRITERE DE MESURES DESECURITE CONTRE L’INCENDIE POUR LES INSTALLATIONS DANS LES MAISONSMANUFACTURES, LES SITES ET LES COMMUNAUTES, ANSI/NFPA 501A. POUR UNEUTILISER AVEC BARRIÈRE W010-3296. SUIVEZ LES INSTRUCTIONS D'INSTALLATION SETROUVENT DANS LE MANUEL D'INSTALLATION.MINIMUM AND MAXIMUM HORIZONTAL VENT LENGTHS ARE 25 INCHES AND 20 FEETRESPECTIVELY FOR TOP VENTED UNITS AND 13 INCHES AND 20 FEET RESPECTIVELYFOR REAR VENTED UNITS.LES LONGUEURS HORIZONTALES MINIMALE ET MAXIMALE SONT 25 POUCES ET 20 PIEDSRESPECTIVEMENT POUR UN EVACUATION VERTICALE ET 13 POUCES ET 20 PIEDSRESPECTIVEMENT POUR UN EVACUATION HORIZONTALE.THE APPLIANCE MUST BE VENTED USING THE APPROPRIATE NAPOLEON VENT KITS. SEEOWNERS INSTALLATION MANUAL FOR VENTING SPECIFICS.PROPER REINSTALLATION AND RESEALING IS NECESSARY AFTER SERVICING THEVENT-AIR INTAKE SYSTEM.L’APPAREIL DOIT EVACUER SES GAZ EN UTILISANT L’ENSEMBLE D’EVACUATION PROPREA NAPOLEON. REFERER AU MANUEL D’INSTALLATION DE PROPRIETAIRE POURL’EVACUATION PRECISE. IL EST IMPORTANT DE BIEN REINSTALLER ET RESCELLERL’EVENT APRES AVOIR ASSURE LE MAINTIEN DU SYSTEME DE PRISE D’AIR.NOT FOR USE WITH SOLID FUELUN COMBUSTIBLE SOLIDE NE DOITPAS ETRE UTILISE AVEC CET APPAREILSERIAL NUMBERNO. DE SERIE9700539 (WSL)4001658 (NAC) 4001659 (WUSA)4001657 (NGZ)SAMPLESAMPLESAMPLEMN, L4M 0G8 CANADANTVS600-1PENT REAR VENT0-4500 0-450031,500 *21,000,000 22,000 *13,00022,050 *14,70063.1%PPHORIZONTALLYONNE D’EAULY.MENT AVECCH WILLS, OTHER THAN THAT SUPPLIED BYPPLIANCE.FOR USE AS A HEATIEMBLE DES64-KTMENT: N’AJOUTEZ PAS A CET APPAREIL AUCUNAU DEVANT ENTRER EN CONTACT AVEC LES FLAMMES AUTRECELUI QUI EST FOURNI AVEC CET APPAREIL PAR LE FABRICANT DÉCORATIF: NE PAS UTI;ISER COMME APPARIEGEEARANCE TO COMBUSTIBLE MATERIALMINIMAUX DES MATERIAUX COMBUSTIBLES:AB 6”C 2”0” TO CEILING FROM STOVE1” TO DIRECT VENT ANDL’EVACUATION B6” TO2EAPPROVED FOSUITABLE FOR MOBILE HOMEH THE CURRENT STANDARD CAN/CCANADA OR IN THE UNITED STATAFETY STANDARD, TITLE 24 CFR, PARTCABLE USE THE STANDARD FOR FIREANUFACTURED HOME INSTALLATIONS, SITES AND COMMUNITUSE WITH BARRIER W010-3296. FOLLOW THE INSTALLATIONIN THE INSTALLATION MANUAL.HOMOLOGUE POUR INSTALLATION DANS UNE CHAMBAIN ET UN STUDIO. APPROPRIE POUR INSTALLAINSTALLATION CONFORME AUX EXIGENCESMAISONS MOBILES EQUIPEES AU GA NORME DE SECURITE ET DE COFR, SECTION 3280. DANS LQUEE, SE REFERER ATE CONTRE L’ITURES,EC