Nilfisk-Advance SR 1900 Troubleshooting Manual

Also see for 56507009: Instructions for use Instructions for use

Nilfisk-Advance SR 1900 Troubleshooting Manual Manual pdf 14 page image

14 - FORM NO. 56043129 - SR 1900Copyright 2007 Nilfisk-Advance. Page 1 of 2 2/21/2007SR 1900PM ChecklistDefect CodesCustomer A needs adjustmentB bindingAddress C dirty or contaminatedD damaged, bent or tornCity St Zip L leaksM missingModel Serial Hours W worn outRefOPERATIONAL INSPECTION ITEMSOKDefect Codes(circle)DoesNotWork1 Check Neutral Safety/Sense Switch operation (To test depress drive pedal and start theengine, it should not start.)A B C2 Engine Starting with pedal in neutral (if it will not start check sensor switchprogramming)starts hard3 Engine Speeds 4 cyl G/P (1200 - 2400 RPM) A low power4 Engine Speeds Diesel (note electrical actuator linkage 1200 - 2400 RPM)5 Drive Pedal Linkage (check for FWD/REV drive and any neutral creep) A B6 Drive System Performance noisy sluggish7 Brakes (check both service & parking) A B W8 Steering excessive play9 Hopper Up/Down (also check operation of the safety hopper support) A B10 Hopper Dump Door Open/Close A B11 Main Broom Raise /Lower <----->12 Side Broom Raise /Lower <----->13 Main Broom On/Off <----->14 Side Broom On/Off <----->15 Headlights, Gauges and Optional Accessories (example rotating beacon, backup alarm)16 Dust Control Filter Shaker & Vacuum Impeller <----->17 Tilt Steering Mechanism and Seat Adjustment lever A B18 Dust Guard (OPT) Water Pump Operation On/OffRefVISUAL INSPECTION ITEMSComments OKDefect Codes(circle)DoesNotWork19 Side Broom Pattern & Height Adj. (min bristle wear 3 inches) 3 O'clock to 11 A B D W20 Side Broom Motor B L21 Hopper Cover Gasket D W22 Hopper Dust Filter & Gasket D W23 Dust Control Vacuum Impeller Motor L24 Hopper Dump Door Cylinder A B L25 Hopper Skirting & Seals (raise hopper to inspect) D M W26 Hopper Dump Door & Seal (raise hopper to inspect) A B D W27 Hopper Lift Cylinder & Hopper Interlock Switch Magnetic Switch A B L28 Main Broom Pattern Adjustment (min bristle wear 2-1/2"6.4cm length)2-3" (5-7 cm) widepatternA B D W29 Main Broom Motor (open left side access door to inspect) B L30 Broom Housing & Door Skirts D M W31 Front tires (check lug nut torque 80FT LB, 108 Nm) Tire Pressure 90 psi L W32 Battery Clean & Water C W33 Engine Air Cleaner Element (inner & outer) Check SVR Indicator C W