Quadra-Fire EXPLRMED-PBK Installation Manual

Also see for EXPLRMED-MBK: Instruction manual Installation manual Owner's manual Owner's manual Owner's manual

Contents

Quadra-Fire EXPLRMED-PBK Installation Manual Manual pdf 3 page image

December 3, 2015 7061-197I 3Explorer II Medium Wood StoveModel: Explorer II Medium Wood StoveLaboratory: IntertekReport No: 10126132PRTType: SafetyStandard: UL 1482-07; ULC S627-00EPA Certification #: 925EPA Certified Emissions: 2.2 grams per hour*LHV Tested Efficiency: 78.3 %**HHV Tested Efficiency: 72.4 %***EPA BTU Output: 11,200 to 35,900 / hr.****Peak BTU/Hour Output: 61,000Vent Size: 6 inchesFirebox Size: 2.42 cubic feetRecommended Wood Length: 20 inchesFuel Orientation: Side-to-SideFuel Seasoned Cord Wood* Weighted average LHV efficiency using Douglas Fir dimension-al lumber and data collected during EPA emissions test.**Weighted average HHV efficiency using Douglas Fir dimen-sional lumber and data collected during EPA emissions test.***A range of BTU outputs based on EPA Default Efficiency andthe burn rates from the low and high EPA tests, using DouglasFir dimensional lumber.****A peak BTU out of the unit calculated using the maximum firsthour burn rate from the High EPA Test and the BTU content ofcordwood (8600) times the efficiency.The Quadra-Fire Explorer Series Wood Stove (ACC) meetsthe U.S. Environmental Protection Agency’s crib wood emis-sion limits for wood heaters sold after May 15, 2015.This wood heater needs periodic inspection and repair forproper operation. It is against federal regulations to operatethis wood heater in a manner inconsistent with operatinginstructions in this manual.1 Important Safety InformationA. Appliance CertificationNOTE: Hearth & Home Technologies, manufacturer ofthis appliance, reserves the right to alter its products, theirspecifications and/or price without notice.C. Mobile Home Approved (USA ONLY)• This appliance is approved for mobile home installa-tions in the USA when not installed in a sleeping roomand when an outside combustion air inlet is provided.• The structural integrity of the mobile home floor, ceil-ing, and walls must be maintained.• The appliance must be properly grounded to the frameof the mobile home with #8 copper ground wire, andchimney must be listed to UL103 HT or a listed UL-1777 full length six inch (152mm) diameter liner mustbe used.• Outside Air Kit, part OAK-ACC must be installed in amobile home installation.Improper installation, adjustment, alteration, service ormaintenance can cause injury or property damage.For assistance or additional information, consult a qualifiedinstaller, service agency or your dealer.• Installation and use of any damaged appliance.• Modification of the appliance.• Installation other than as instructed by Hearth & HomeTechnologies.• Installation and/or use of any component part not approvedby Hearth & Home Technologies.• Operating appliance without fully assembling allcomponents.• Operating appliance without legs attached (if supplied withit).• Do NOT Overfire - If appliance or chimney connector glows,you are overfiring.Any such action that may cause a fire hazard.WARNINGFire Risk.Hearth & Home Technologies disclaims anyresponsibility for, and the warranty will be voidedby, the following actions:B. BTU & Effi ciency SpecificationsHearth & Home Technologies WILL NOT warranty stovesthat exhibit evidence of over-firing. Evidence of over-firingincludes, but is not limited to:• Warped air tube• Deteriorated refractory brick retainers• Deteriorated baffle and other interior componentsE. Non-Combustible MaterialsMaterial which will not ignite and burn, composed of anycombination of the following:- Steel - Plaster- Brick - Iron- Concrete - Tile- Glass - SlateMaterials reported as passing ASTM E 136, StandardTest Method for Behavior of Metals, in a Vertical TubeFurnace of 750° C.F. Combustible MaterialsMaterial made of/or surfaced with any of the following ma-terials:- Wood - Compressed Paper- Plant Fibers - Plastic- Plywood/OSB - Sheet Rock (drywall)Any material that can ignite and burn: flame proofed or not,plastered or un-plastered.D. Glass Specifi cationsThis stove is equipped with 5mm ceramic glass. Replaceglass only with 5mm ceramic glass. Please contact yourdealer for replacement glass.