Raypak 1005-2005 Specification Sheet

Also see for 1005-2005: Specifications Installation & operating instructions

Contents

water heaters

Catalog No.: 6000.37 Effective: 9-15-08 Replaces: NEWJob:Engineer:Contractor:Prepared By: Date:Model: Indoor/Outdoor:97% Thermal Efficiency at Full Rate; Up to 99% at Part Load100% Factory Fire TestedMaximum Outlet Water Temperature: 160°FMinimum Acceptable Inlet Water Temperature: 50°FFull Safety Diagnostics with HistoryFootprint: Less Than 10.8 ft 2Limited Twenty-Five-Year Thermal Shock WarrantyLimited Ten-Year Primary Heat Exchanger WarrantyLimited Five-Year Secondary Heat Exchanger WarrantyFull Electronic Modulation, Constant Ratio 4:1 TurndownDigital Controller with LCD DisplayStatus Display LightsHeat Exchanger Bronze Headers ASME HLW Stamped; 160 PSIGMAWP National Board Listed Cupro Nickel Fin Tubing ASME Powder-Coated Tube Sheet Silicone High Temp O-Rings ASME Pressure Relief Valve125 PSIG – Standard (Loose) 150 PSI Air Vent, Auto T&P Gauge (Loose) Stainless Steel Secondary HeatExchanger Stainless Steel Evaporator Plate Boiler Pump: Bronze, HP,120V, 1∅, 60HzControl 120V, 60Hz, 1Ø, Power Supply 120/24V 60Hz Transformer Ignition Module3-Try – StandardSingle-Try – Option C-6 Hot Surface Ignition (HSI) Remote Flame Sensor High Limit Control, Auto Reset On/Off Power Switch Flow Switch Blocked Vent Pressure Switch Combustion Air Proving Switch Freeze Protection Pump Switch Pump Time Delay Blocked Condensate SwitchControl (cont.) Diagnostics Panel with LCD Display,2 lines, 20 characters Digital Temperature Control Water Temperature Sensors (3) Cold Water ProtectionBurner Ultra-Low NOx: Less than 20 PPM(Natural Gas Only)Gas Train FuelNatural GasPropane Zero Governor Regulator Dual-Seat Combination Valve Electronic Firing Mode (WHP)Construction Indoor/Outdoor Construction Front Controls Enclosed PolyTuf Powder Coat Finish Rear Connections (Water, Gas, Vent,Electrical, Comb. Air, Cond. Drain) Combustion Air Filter Design Certified ANSI Z21.10.3/CSA 4.3Venting Vent TerminationOutdoor or Indoor, Vertical –Option D-11Indoor, Horizontal – Option D-15 Extractor - OptionalBy othersNot requiredMulti-Boiler Digital Temp ControllersB-36 TempTracker Mod+,2-4 Water HeatersB-37 TempTracker Mod+,5-10 Water HeatersB-38 TempTracker Mod+,11-16 Water HeatersOptionsF-10 Low Water Cut-Off, RemoteProbeI-5 High Limit, Manual Reset,Adj., 100-200°FS-1 Low Gas Pressure Switch,Manual ResetS-2 High Gas Pressure Switch,Manual ResetZ-12 Condensate Neutralizer KitRegulatory Agency RequirementsXTherm ™ - Type WHPWater HeatersModels 1005-2005

/ 2

Related manuals for Raypak 1005-2005