Raypak 2600401 Installation & Operating Instructions Manual

Also see for 260: Installation & operating instructions Installation and operating instructions Brochure & specs

Raypak 2600401 Installation & Operating Instructions Manual Manual pdf 4 page image

4DANGER: Indicates the presence of immediate hazards which will cause severepersonal injury, death or substantial property damage if ignored.WARNING: Indicates the presence of hazards or unsafe practices which could causesevere personal injury, death or substantial property damage if ignored.CAUTION: Indicates the presence of hazards or unsafe practices which could causeminor personal injury or product or property damage if ignored.NOTE: Indicates special instructions on installation, operation, or maintenance whichare important but not related to personal injury hazards.WARNINGS— Pay Attention to These TermsWARNING: Gasoline, as well as other flammablematerials and liquids (adhesives, solvents, etc.), andthe vapors they produce, are extremely dangerous.DO NOT handle, use or store gasoline or otherflammable or combustible materials anywhere nearor in the vicinity of a water heater. Be sure to readand follow the warning label pictured below andother labels on the water heater, as well as thewarnings printed in this manual. Failure to do so canresult in property damage, bodily injury, or death.Vapors fromflammable liquids willexplode and catch firecausing death or severeburns.Do not use or store flammableproducts such as gasolinesolvents or adhesives in thesame room or area near thewater heater.Keep flammable products:1. far away from heater,2. in approved containers,3. tightly closed and4. out of childrenʼs reach.Water heater has a mainburner and pilot flame.The pilot flame:1. is on all the time and2. will ignite flammablevapors.Vapors:1. cannot be seen,2. are heavier than air,3. go a long way on thefloor,4. can be carried from otherroom to the pilot flame bytheir currents.Installation:Do not install water heaterwhere flammable productswill be stored or used unlessthe main burner and pilot flamesare at least 18" above thefloor. This will reduce, butnot eliminate, the risk ofvapors being ignited by themain burner or pilot flame.Read and follow water heater warnings and instructions. If ownersmanual is missing, contact the retailer or manufacturer.DANGER: Failure to install the draft hood andproperly vent the water heater to the outdoors asoutlined in the Venting section of this manual canresult in unsafe operation of the water heater. Toavoid the risk of fire, explosion, or asphyxiation fromcarbon monoxide, never operate this water heaterunless it is properly vented and has an adequate airsupply for proper operation. Be sure to inspect thevent system for proper installation at initial start-up;and at least annually thereafter. Refer to theMaintenance section of this manual for moreinformation regarding vent system inspections.DANGER: Water heaters utilizing LiquefiedPetroleum gas (LP) are different from natural gasmodels. A natural gas heater will not function safelyon LP gas and vice versa. Conversion from Naturalgas to LP gas (or vice versa) must be done by aqualified service technician. To avoid possibleequipment damage, personal injury or fire: DO NOTconnect this water heater to a fuel type not inaccordance with unit data plate. Propane forpropane units, Natural gas for natural gas units.These units are not certified for any other type fuel.DANGER: LIQUEFIED PETROLEUM MODELS:Propane, or LP gas, must be used with greatcaution.• It is heavier than air and will collect first in lowerareas making it hard to detect at nose level.• Make sure to look and smell for LP leaks beforeattempting to light appliance. Use a soapy solution tocheck all gas fittings and connections. Bubbling at aconnection indicates a leak that must be corrected.When smelling to detect an LP leak, be sure to sniffnear the floor too.• Gas detectors are recommended in LP applicationsand their installation should be in accordance withthe manufacturer's recommendations and/or locallaws, rules, regulations or customs.• It is recommended that more than one method beused to detect leaks in LP applications.WARNING: LP appliances should not be installedbelow-grade (for example, in a basement) if suchinstallation is prohibited by federal, state and/or locallaws, rules, regulations or customs.