Tanaka TCH 22EAP2 Handling Instructions Manual

Also see for TCH 22EA2: Handling instructions Handling instructions Handling instructions

Contents

Tanaka TCH 22EAP2 Handling Instructions Manual Manual pdf 6 page image

6EnglishWARNINGS AND SAFETY INSTRUCTIONSKeep for future reference.THIS HEDGE TRIMMER CAN CAUSE SERIOUS INJURIES. Readthe instructions carefully for the correct handling, preparation,maintenance, starting and stopping of the hedge trimmer. Becomefamiliar with all controls and the proper use of the hedge trimmer.Operator safety○ Always wear a safety face shield or goggles.○ Always wear heavy, long pants, boots and gloves. Do not wearloose clothing, jewelry, short pants, sandals or go barefoot.Secure hair so it is above shoulder length.○ Do not operate this tool when you are tired, ill or under theinfluence of alcohol, drugs or medication.○ Never let a child or inexperienced person operate the machine.○ Beware of overhead power lines.○ Wear hearing protection.○ Never start or run the engine inside a closed room or building.Breathing exhaust fumes can kill.○ Keep handles free of oil and fuel.○ Keep hands away from cutting equipment.○ Do not grab or hold the unit by the cutting equipment.○ When the unit is turned off, make sure the cutting attachmenthas stopped before the unit is set down.○ When operation is prolonged, take a break from time to timeso that you may avoid possible Hand-Arm Vibration Syndrome(HAVS) which is caused by vibration.○ If the cutting mechanism strikes any foreign object or thehedge trimmer starts making any unusual noise or vibration,shut off the power source and allow the hedge trimmer to stop.Disconnect the spark plug wire from the spark plug and take thefollowing steps:• Inspect for damage;• Check for, and tighten, any loose parts;• Have any damaged parts replaced or repaired with partshaving equivalent specifications.WARNING○ Antivibration systems do not guarantee that you will not sustainHand-Arm Vibration Syndrome or carpal tunnel syndrome.Therefore, continual and regular users should monitor closelythe condition of their hands and fingers. If any symptoms of theabove appear, seek medical advice immediately.○ If you are using any medical electric/electronic devices suchas a pacemaker, consult your physician as well as the devicemanufacturer prior to operating any power equipment.○ When a foreign object is caught in the blade, turn off theengine, and remove the foreign object carefully using a plieretc., after the hedge trimmer has been cooled down. Be carefulwhen removing the foreign object, since the blade may movebecause of the backlash.Unit/machine safety○ Inspect the entire unit/machine before each use. Replacedamaged parts. Check for fuel leaks and make sure allfasteners are in place and securely tightened.○ Replace parts that are cracked, chipped or damaged in any waybefore using the unit/machine.○ Keep others away when making carburetor adjustments.○ Use only accessories as recommended for this unit/machine bythe manufacturer.WARNINGNever modify the unit/machine in any way. Do not use your unit/machine for any job except that for which it is intended.Fuel safety○ Mix and pour fuel outdoors and where there are no sparks orflames.○ Use a container approved for fuel.○ Never remove the fuel cap or add fuel with the power sourcerunning. Allow engine and exhaust components to cool downbefore refuelling.○ Do not smoke or allow smoking near fuel or the unit/machine orwhile using the unit/machine.○ Never refuel indoors.○ Wipe up all fuel spills before starting engine.○ Move at least 3 m away from fueling site before starting engine.○ Stop engine before removing fuel cap.○ Empty the fuel tank before storing the unit/machine. It isrecommended that the fuel be emptied after each use. If fuel isleft in the tank, store so fuel will not leak.○ Store unit/machine and fuel in area where fuel vapors cannotreach sparks or open flames from water heaters, electric motorsor switches, furnaces, etc.WARNINGFuel is easy to ignite or get explosion or inhale fumes, so thatpay special attention when handling or filling fuel.Cutting safety○ Do not cut any material other than plant hedge.○ Inspect the area to be cut before each use. Remove objectswhich can be thrown or become entangled.○ For respiratory protection, wear an aerosol protection maskwhen cutting the grass after insecticide is scattered.○ Keep others including children, animals, bystanders andhelpers outside the 15 m hazard zone. Stop the engineimmediately if you are approached.○ Hold the unit/machine firmly with both hands.○ Keep firm footing and balance. Do not over-reach.○ Keep all parts of your body away from the muffler and cuttingattachment when the engine is running.○ Keep cutting tool below shoulder level. NEVER operate unitfrom a ladder, while in a tree or from any unstable support.○ When relocating to a new work area, be sure to shut off themachine and ensure that all cutting attachments are stopped.○ Never place the machine on the ground when running.○ Always carry a first-aid kit when operating any powerequipment.○ Never start or run the engine inside a closed room or buildingand/or near the inflammable liquid. Breathing exhaust fumescan kill.Maintenance safety○ Maintain the unit/machine according to recommendedprocedures.○ Disconnect the spark plug before performing maintenanceexcept for carburetor adjustments.○ Keep others away when making carburetor adjustments.○ Use only genuine Tanaka replacement parts as recommendedby the manufacturer.○ When the hedge trimmer is stopped for servicing, inspection orstorage, shut off the power source, disconnect the spark plugwire from the spark plug and make sure all moving parts havecome to a stop.Allow the hedge trimmer to cool before making any inspection,adjustments, etc.Transport and storage○ Carry the unit/machine by hand with the engine stopped andthe muffler away from your body.○ Allow the engine to cool, empty the fuel tank, and secure theunit/machine before storing or transporting in a vehicle.○ Empty the fuel tank before storing the unit/machine. It isrecommended that the fuel be emptied after each use. If fuel isleft in the tank, store so fuel will not leak.○ Store unit/machine out of the reach of children.○ Clean and maintenance the unit carefully and store it in a dryplace.○ Make sure engine switch is off when transporting or storing.○ When transporting in a vehicle or storage, cover blade withblade cover.If situations occur which are not covered in this manual, take careand use common sense. Contact your Tanaka dealer if you needassistance. Pay special attention to statements preceded by thefollowing words:WARNINGIndicates a strong possibility of severe personal injury or loss oflife, if instructions are not followed.CAUTIONIndicates a possibility of personal injury or equipment damage,if instructions are not followed.