lancer 4500 Series Installation Manual

Also see for 4500 Series: Operation manual Operation manual Installation and service manual

Contents

specifications

lancer 4500 Series Installation Manual Manual pdf 2 page image

2• WARNING: Carbon Dioxide (CO2) is a colorless, noncombustible gas with a light pungent odor. High percentages of CO2 maydisplace oxygen in the blood.• WARNING: Prolonged exposure to CO2 can be harmful. Personnel exposed to high concentrations of CO2 gas will experiencetremors which are followed by a loss of consciousness and suffocation.• WARNING: If a CO2 gas leak is suspected, immediately ventilate the contaminated area before attempting to repair the leak.• WARNING: Strict attention must be observed in the prevention of CO2 gas leaks in the entire CO2 and soft drink system.5 Carbon Dioxide (CO2)Units are equipped with an automatic agitation system and will activate unexpectedly. Do not place hands or foreign objects in theice bin. Unplug the dispenser during servicing, cleaning, and sanitizing. To avoid personal injury, do not attempt to lift the dispenserwithout assistance. For heavier dispensers, use a mechanical lift.! Automatic AgitationProvide an adequate potable water supply. Water pipe connections and fixtures directly connected to a potable water supply mustbe sized, installed, and maintained according to federal, state, and local laws. The water supply line must be at least a 3/8 inches(9.525 mm) pipe with a minimum of 25 PSI (0.172 MPA) line pressure, but not exceeding a maximum of 50 PSI (0.345 MPA).Water pressure exceeding 50 PSI (0.345 MPA) must be reduced to 50 PSI (0.345 MPA) with the provided pressure regulator. Usea filter in the water line to avoid equipment damage and beverage off-taste. Check the water filter periodically, as required by localconditions. The water supply must be protected by means of an air gap, a backflow prevention device or another approved methodto comply with NSF standards. A leaking inlet water check valve will allow carbonated water to flow back through the pump when itis shut off and contaminate the water supply. Ensure the backflow prevention device complies with ASSE and localstandards. It is the responsibility of the installer to ensure compliance.! Water NoticeSPECIFICATIONSDIMENSIONSWidth: 22.0 inches (559 mm)Depth: 30.5 inches (775 mm)Height: 34 inches (864 mm)WEIGHTShipping: 255 lbs (116 kg)Empty: 225 lbs (102 kg)Ice Capacity: 180 lbs (82 kg)Ice Dispensable: 150 lbs (68 kg)CARBON DIOXIDE (CO2) SUPPLYMin Pressure: 70 PSIG (0.483 MPA)Max Pressure: 80 PSIG (0.552 MPA)FITTINGSPlain/Carb Water Inlet: 3/8 inch barbBrand Syrup Inlets: 3/8 inch barbELECTRICAL115 VAC / 60 Hz / 3.0 Amps230 VAC / 50-60 Hz / 1.5 AmpsPLAIN WATER SUPPLYMin Flowing Pressure: 25 PSIG (0.172 MPA)Max Flowing Pressure: 50 PSIG (0.345 MPA)CARBONATED WATER SUPPLYMin Flowing Pressure: 25 PSI (0.172 MPA)Max Static Pressure: 50 PSI (0.345 MPA)IBD 4500 - 22”This unit emits a soundpressure level below 70 dBCARBON DIOXIDE (CO2) SUPPLYMin Pressure: 70 PSIG (0.483 MPA)Max Pressure: 80 PSIG (0.552 MPA)FITTINGSPlain/Carb Water Inlet: 3/8 inch barbBrand Syrup Inlets: 3/8 inch barbDIMENSIONSWidth: 25.0 inches (635 mm)Depth: 30.5 inches (775 mm)Height: 34 inches (864 mm)WEIGHTShipping: 285 lbs (129.3 kg)Empty: 250 lbs (113.4 kg)Ice Capacity: 210 lbs (95.2 kg)Ice Dispensable: 170 lbs (77.1 kg)ELECTRICAL115 VAC / 60 Hz / 3.6 Amps230 VAC / 50-60 Hz / 1.8 AmpsPLAIN WATER SUPPLYMin Flowing Pressure: 25 PSIG (0.172 MPA)Max Flowing Pressure: 50 PSIG (0.345 MPA)CARBONATED WATER SUPPLYMin Flowing Pressure: 25 PSI (0.172 MPA)Max Static Pressure: 50 PSI (0.345 MPA)IBD 4500 - 25”This unit emits a soundpressure level below 70 dB