DAELIM a.four Service Manual

Also see for A-FOUR -: Brochure

Contents

DAELIM a.four Service Manual Manual pdf 141 page image

13-113. CHARGING SYSTEM/A.C.GENERATORSERVICE INFORMATION·Do not place flammable materials near battery when charging. This can be a fire hazard as hydrogen gas is createdduring charging battery.·Do not allow battery acid to come into contact with clothes, skin or eyes. Battery acid contact can cause burns or loss ofeye sight. If contact occurs, thoroughly clean with water, and if acid enters eyes, flush with water and see a doctor.·If battery acid gets on clothing, as it can seep through or make a hole through the clothing and make its way to the skin,make sure to change clothing that has come into contact with battery acid and wash the battery acid from the clothes.·This vehicle has a maintenance-free(MF) battery. Because MF batteries use different charging equipment, take specialcare when performing maintenance and especially when replacing parts. Not all regular battery equipment iscompatible with MF batteries.·When charging the battery, remove the battery from the frame and do not open stopper.·There is the possibility of damaging the regulator/rectifier, etc. if the terminal or coupler is separated/connected whenelectricity is over flowing through the electrical devices. Make sure to turn the main switch OFF when performingmaintenance to the charging equipment.● If the battery is allowed to repeatedly lose all its charge, is repeatedly over-charged, or if it is left in an un-charged state,the battery can be damaged, its life can be reduced, or it can lose some of its strength. It is important to note here that thebattery will naturally last 2-3 years of noromal use, and although it will re-charge, its load is reduced, leading to a loss inbattery strength.● It is possible for the battery to become overcharged from battery body load. If a battery cell becomes short-circuited andif a state develops where voltage is not created between the terminals, the regulator will not operate and excessivevoltage will develops where voltage is not created between the terminals, the regulator will not operate and excessivevoltage will develop in the battery and normal cell electrolytes will decrease.● If the vehicle is not used for a long period, make sure to chage the battery every three months. If not so, the batteryability to store electricity is reduced.● A new MF battery will not necessarily be ready for use in the vehicle with only the adding of battery acid. Make sure tocharge battery after the adding of battery water in the following instances :-When open voltage (voltage between terminals) does not reach 12.4V after the adding of battery water : charge untilopen voltage reaches at least 12. 8V.-When battery acid temperature is under 0℃ : charge normally for 2-3 hours.● See the part location drawing for the location of charging system parts. ( 13-2 )● Follow the trouble shooting for charging equipment inspection. ( 13-3 )● The charging equipment may ofter appear to be malfunctioning if the couplers or connectors are incorrectly attached.Make sure to check these connections before starting maintenance work on the charging equipment.13SERVICE INFORMATION 13-1CHARGING DEVICES LOCATION 13-2TROUBLESHOOTING 13-3BATTERY REMOVAL/INSTALLATION 13-4BATTERY INSPECTION 13-4CHARGING SYSTEM INSPECTION 13-4HEADLIGHT VOLTAGE INSPECTION 13-6REGULATOR/RECTIFIER INSPECTION 13-6A.C. GENERATOR 13-7RESISTER INSPECTION 13-9