Nexgrill 720-0309 Assembly & Operating Instructions

Contents

Nexgrill 720-0309 Assembly & Operating Instructions Manual pdf 16 page image

Check all gas supply fittings for leaks beforeeach use. It is handy to keep a spray bottle ofsoapy water near the shut-off valve of the gassupply line. Spray all the fittings. Bubblesindicate leaks.LEAK TESTGAS FLOW CHECKEach grill burner is tested and adjusted at thefactory prior to shipment; however, variations inthe local gas supply may make it necessary toadjust the burners. The flames of the burnersshould be visually checked.Flames should be blue and stable with noyellow tips, excessive noise or lifting. If any ofthese conditions exist, check to see if the airshutter or burner ports are blocked by dirt,debris, spider webs, etc. If you have anyquestions regarding flame stability, please callcustomer service 1-866-984-7455Disconnected L.P. cylinders must havethreaded valve plugs tightly installed, andmust not be stored in a building, garage or anyother enclosed area.The gas must be turned off at the supplycylinder when the unit is not in use.If the appliance is stored indoors the cylindermust be disconnected and removed from theappliance. Cylinders must be stored outdoorsin a well-ventilated area out of the reach ofchildren.•Have your LP gas tank filled by a reputable propane gas • dealer and visually inspected and re-qualified ateach • filling.• a ) Do not store a spare LP gas cylinder under ornear this appliance.• b) Never fill the cylinder beyond 80 percent full .• c) If the information in a) and b) is not followedexactly a fire causing death or serious injury mayoccur.• Always keep LP gas tanks in an upright position. • Do not store (or) or use gasoline or other flammable• vapors and liquids in the vicinity of this gas grill. •Do not subject the LP gas tank to excessive heat.• Never store an LP gas tank indoors. If you store your gas grill in the garage or other indoor location,always disconnect the LP gas tank first and store it safely outside.• Place dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of dustcap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugsmay result in leakage of propane.• LP gas tanks must be stored outdoors in a well-ventilated area and out of reach of children.Disconnected LP gas tanks must not be stored in a building, garage or any other enclosed area.• When your gas grill is not in use the gas must be turned off at the LP gas tank.• The regulator and hose assembly must be inspected before each use of the grill. If there is excessiveabrasion or wear or if the hose is cut, it must be replaced prior to the grill being used again.• Keep the gas regulator hose away from hot grill surfaces and dripping grease. Avoid unnecessarytwisting of hose. Visually inspect the hose prior to each use for cuts, cracks, excessive wear orother damage. If the hose appears damaged do not use the gas grill. Call 1-800-361-6665 for aSears authorized replacement hose.14• Never light your gas grill with the lid closed or before checking to ensure the burner tubes are fullyseated over the gas valve orifices.OPERATING INSTRUCTIONS