NightStick XPR-5561G Instruction Manual

Also see for XPR-5561G: Instruction manual

NightStick XPR-5561G Instruction Manual Manual pdf 1 page image

Bayco Products, Inc. • 640 South Sanden Blvd. • Wylie, TX 75098 • USA • 1-800-233-2155 • 1-469-326-9400 • www.nightstick.comINS-XPR-5561-DL-19 02-26-2019Instruction ManualXPR-5561GPlease read these instructions before using your Nightstick XPR-5561GIntrinsically Safe Permissible Rechargeable Cap Lamp. They include importantsafety information and operating instructions.THE XPR-5561G IS APPROVED FOR USECLASS I DIV 1 GRPS A-D T4CLASS II & III DIV1 GRPS E-G T135°CCLASS I ZONE 0 AEx ia IIC T4 GaCLASS I ZONE 0 Ex ia IIC T4 GaEx ia I MaEx ia IIC T4 GaDEMKO 17 ATEX 1826IECEx UL 17.0005-20ºC ≤ Tamb ≤ +40ºC3.7V/Cell Li-ionUm: 10V0359E 467756INTRINSICALLY SAFESECURITE INTRINSEQUEI M1 Ex ia I MaII 1 G Ex ia IIC T4 GaBayco Products, Inc.640 S. Sanden Blvd., Wylie, TX 75098Ex ia FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONSUL listed for use with Bayco Li-ion Battery Pack 5560-BATTWARNING: Do not charge battery in a hazardous locationWARNING: Do not replace battery when an explosiveatmosphere is presentID 4003544Model XPR-5561 Permissible Cap Lamp AssemblyAPPROVAL No. 19-A160003-1TESTED FOR INTRINSIC SAFETY IN METHANE-AIR MIXTURES ONLYWARNINGS:1) Only to be charged on the surface, or underground in accordance with the applicableregulations pertaining to battery-charging stations (reference 30 CFR 75.340) with a BaycoProducts, Inc. Model 5560-CHGR22) Do not open in areas where permissibility is required.WARNINGS - INTRINSICALLY SAFEy Warning: To prevent ignition of a hazardous atmosphere, the XPR-5561Gmust only be charged in an area known to be non-hazardous.y Warning: Use only the approved Nightstick 5560-BATT Lithium-ionrechargeable battery pack.y Warning: To prevent ignition of a hazardous atmosphere, do not openthe battery compartment or attempt to exchange the battery pack while inthe hazardous environment. This task must ONLY be performed in an areaknown to be non-hazardous.y Warning: Open the battery compartment on the XPR-5561G and replacethe approved Nightstick 5560-BATT Lithium-ion rechargeable battery packin fresh air only. To maintain IP rating, torque battery compartment screwsto 3.5 in-lb.y Warning: replacement of the Lithium-ion rechargeable battery pack mustbe performed by a quallified technician only.y Warning: Substitution of components may impair intrinsic safety.SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETYFor personal safety, always confirm the rating of any known hazardous orpotentially hazardous location where the XPR-5561G is to be used.CAUTIONy Rechargeable Lithium-ion batteries must be used and charged properly.Improper use can result in serious injury, fire, or death.y Do not leave the battery in direct sunlight or use or store the battery insidecars in hot weather.y Do not expose the battery to water or salt water, or allow the battery toget wet.y Do not store the battery with metallic objects that may cause a short circuit.y Immediately discontinue use of the battery if the battery emits an unusualsmell, feels hot, changes color, changes shape or appears abnormal in any way.y Keep out of the reach of children.CHARGING THE LIGHTWARNING: Use only the supplied 5560-CHGR2 Charger & approvedNightstick Lithium-ion Rechargeable Battery Pack.y The time required to charge the 5561 is conditional on the remainingcharge left in the Lithium-ion Rechargeable Battery Pack at the time ofcharging. The maximum charge time required is approximately 6 hours.y Fully charge the 5561 before the first use, or if the 5561 has been unusedfor several months.y When the 5561 is properly seated in the charger, the LED Charge Indicatorlight will turn solid RED indicating that the Lithium-ion Rechargeable BatteryPack is charging. The Lithium-ion Rechargeable Battery Pack is fullycharged when the LED Charge Indicator light turns GREEN.y The Lithium-ion Rechargeable Battery Pack does not have any RechargeMemory Effect; therefore placing the 5561 in the charger prior to fulldepletion of the battery does not adversely affect the battery life. The 5561can be kept in the charger indefinitely without any negative impact on thebattery or the battery life.OPERATIONThe XPR-5561G is controlled by 2 Switches and has 6 separate lightingmodes:y High-brightness Spotlighty Low-brightness Spotlighty Spotlight Beacony High-brightness Floodlighty Survival-mode Floodlighty Dual-Light (both the Spotlight and Floodlight on at the same time)Spotlight ModesTo activate the spotlight, press and release the spotlight switch. Thedefault mode will be low-brightness. Press the spotlight switch a second timeto activate the high-brightness mode. To activate the spotlight beacon pressand hold the spotlight button until the beacon turns on. Press the spotlightswitch a third time to turn the light off.Floodlight ModesTo activate the floodlight, press and release the floodlight switch. Thedefault mode will be high-brightness. To select the survival mode, press thefloodlight switch a second time. Press the floodlight switch a third time to turnthe light off.Dual-Light ModeDual-Light mode allows the user to turn on both the spotlight and thefloodlight at the same time. Dual-Light mode can be activated by simplypressing the spotlight switch and then the floodlight switch. If the 5561already has the spotlight or the floodlight on (regardless of what brightnessmode that light is in), pressing the switch for the light that is NOT on, willactivate Dual-Light mode. The user can leave Dual-Light mode and go backto either spotlight or floodlight mode simply by pressing the switch for themode that they wish to turn off. To turn both lights off, simply press each ofthe switches independently.Low Battery WarningThe XPR-5561G has a Low Battery Warning feature. Once the batterycharge falls below 2.9V, the Spotlight LED will blink once every minute whilethe light is on regardless of which of the 5 modes the 5561 is in at the time.The Spotlight LED will continue to flash until the battery is fully depleted oruntil the 5561 is recharged to have a remaining charge capacity greater than2.9V. This warning feature is an indication that the 5561 should be charged assoon as is possible. If the 5561 is off, no such warning will take place.WARRANTYLIMITED LIFETIME WARRANTYBayco Products, Inc. warrants this product to be free from defects inworkmanship and materials for the original purchaser’s lifetime. The LimitedLifetime Warranty includes the LEDs, housing and lenses. Rechargeable