Quadra-Fire CASTILE-MBK-B Installation Manual

Also see for CASTILE-CSB-B: Owner's manual installation and operation Owner's manual Owner's manual Owner's manual Owner's manual

Quadra-Fire CASTILE-MBK-B Installation Manual Manual pdf 3 page image

May 12, 2017 7021-154J 3CASTILE F R E E S TANDINGModel Castile Pellet ApplianceLaboratory OMNI Test Laboratories, Inc.Report No. 061-S-77d-6.2Type Solid Fuel Room Appliance/Pellet FuelBurning TypeStandard ASTM E1509-04, ULC S627-00 andULC/ORD-C1482-M1990 Room Appli-ance Pellet Fuel Burning type and (UM)84-HUD, Mobile Home Approved.FCC Complies with Part 15 of FCC Rules.Operation is subject to the followingtwo conditions: (1) this device may notcause harmful interference, and (2) thisdevice must accept any interferencereceived, including interference that maycause undesired operation.1 Important Safety InformationNOTE: Hearth & Home Technologies, manufacturer ofthis appliance, reserves the right to alter its products, theirspecifications and/or price without notice.Improper installation, adjustment, alteration, service ormaintenance can cause injury or property damage.For assistance or additional information, consult a qualifiedinstaller, service agency or your dealer.Quadra-Fire is a registered trademark of Hearth & HomeTechnologies.• Installation and use of any damaged appliance.• Modification of the appliance.• Installation other than as instructed by Hearth & HomeTechnologies.• Installation and/or use of any component part not approved byHearth & Home Technologies.• Operating appliance without fully assembling all components.• Operating appliance without legs attached (if supplied withappliance).• Do NOT Over fire - If appliance or chimney connector glows,you are over firing.Any such action that may cause a fire hazard.WARNINGFire Risk.Hearth & Home Technologies disclaims anyresponsibility for, and the warranty will be voided by,the following actions:C. Glass SpecificationsThis appliance is equipped with 5mm ceramic glass.Replace glass only with 5mm ceramic glass. Please con-tact your dealer for replacement glass.D. Electrical Rating115 VAC, 60 Hz, Start 4.1 Amps, Run 1.1 AmpsE. Mobile Home Approved• This appliance is approved for mobile home installa-tions when not installed in a sleeping room and whenan outside combustion air inlet is provided.• The structural integrity of the mobile home floor, ceil-ing, and walls must be maintained.• The appliance must be properly grounded to theframe of the mobile home and use only Listed pelletvent Class “L” or “PL” connector pipe.• Outside Air Kit, part OAK-ACC must be installed in amobile home installation.NOTICE: This installation must conform with local codes. Inthe absence of local codes you must comply with the ASTME1509-04, ULC S627-00, (UM) 84-HUD and ULC/ORD-C-1482.A. Appliance CertificationB. BTU & Efficiency SpecificationsThe Quadra-Fire Castile Pellet Appliance meets the U.S.Environmental Protection Agency’s emission limits for pelletappliances sold after May 15, 2015.This pellet appliance needs periodic inspection and repair forproper operation. It is against federal regulations to operatethis pellet appliance in a manner inconsistent with operatinginstructions in this manual.EPA Certification #: 940-14EPA Certified Emissions: 1.8 grams per hour*LHV Tested Efficiency: N/A**HHV Tested Efficiency: N/A***EPA BTU Output: 8,500 to 28,200 / hr.****BTU Input: 11,600 to 38,700 / hr.Vent Size: 3 or 4 inches, L or PLHopper Capacity: 40 lbs. +/- 5 lbs.Fuel Wood Pellets* Weighted average LHV efficiency using data collected duringEPA emissions test.**Weighted average HHV efficiency using data collected duringEPA emissions test.***A range of BTU outputs based on EPA Default Efficiency andthe burn rates from the low and high EPA tests.****Based on the maximum feed rate per hour multiplied byapproximately 8600 BTU’s which is the average BTU’s from apound of pellets.