Yamaha FZ8NA Service Manual

Also see for Fazer FZ8-SA: Owner's manual Owner's manual Owner's manual

FUEL TANK7-2EAS39P1713REMOVING THE FUEL TANK COVER1. Remove:• Fuel tank cover “1”▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼▼a. Remove the bolts.b. Disengage the projections from both endsof the fuel tank, slightly expanding bothends of the fuel tank cover.c. Slide the right side of the fuel tank coverslightly forward to disengage projections“a” from the fuel tank cover bracket. Addi-tionally, lift the rear of the cover (like turningover the cover) to disengage projection “b”from the cover bracket.▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲▲EAS39P1701REMOVING THE FUEL TANK1. Extract the fuel in the fuel tank through thefuel tank cap with a pump.2. Remove:• Fuel tank cover• Fuel hose connector cover3. Disconnect:• Fuel hose (fuel tank side)• Fuel sender coupler• Fuel pump coupler• Fuel tank drain hose• Fuel tank breather hoseWARNINGEWA39P1702Cover fuel hose connection with a clothwhen disconnecting them. Residual pres-sure in the fuel lines could cause fuel tospurt out when removing the hose.ECA14B1003Be sure to disconnect the fuel hose byhand. Do not forcefully disconnect the hosewith tools.TIP• To remove the fuel hose from the fuel pump,press the two buttons “1” on the sides of theconnector, and then remove the hose.• Before removing the hose, place a few ragsin the area under where it will be removed.• It is prohibited to wear the cotton work glovesor equivalent coverings.4. Remove:• Fuel tankTIPDo not set the fuel tank down so that the instal-lation surface of the fuel pump is directly underthe tank. Be sure to lean the fuel tank in anupright position.EAS26640REMOVING THE FUEL PUMP1. Remove:• Fuel pumpECA14720• Do not drop the fuel pump or give it astrong shock.• Do not touch the base section of the fuelsender.EAS39P1702CHECKING THE FUEL PUMP BODY1. Check:• Fuel pump bodyObstruction → Clean.Cracks/damage → Replace fuel pumpassembly.