Carrier 48TM016-028 Installation, Start-up And Service Instructions Manual

Also see for 48TM016: User's information manual

Contents

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.Catalog No. 04-53480016-01 Printed in U.S.A. Form 48TM-4SI Pg CL-1 3-06 Replaces: 48TM-3SIBook 1 4Tab 1a 6aCopyright 2006 Carrier Corporation- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -- - - - - - - - - - - - - - - - - - - -CUT ALONG DOTTED LINE CUT ALONG DOTTED LINESTART-UP CHECKLISTPRE-START-UP VERIFY THAT ALL PACKING MATERIALS HAVE BEEN REMOVED FROM UNIT VERIFY INSTALLATION OF INDOOR FAN MOTOR ADJUSTMENT BOLT AND PLATE VERIFY INSTALLATION OF OUTDOOR-AIR HOOD VERIFY INSTALLATION OF FLUE HOOD AND WIND BAFFLE VERIFY THAT CONDENSATE CONNECTION IS INSTALLED PER INSTRUCTIONS VERIFY THAT ALL ELECTRICAL CONNECTIONS AND TERMINALS ARE TIGHT CHECK GAS PIPING FOR LEAKS CHECK THAT FILTERS AND SCREENS ARE CLEAN AND IN PLACE VERIFY THAT UNIT IS LEVEL CHECK FAN WHEEL AND PROPELLER FOR LOCATION IN HOUSING/ORIFICE, AND VERIFY SETSCREWIS TIGHT VERIFY THAT FAN SHEAVES ARE ALIGNED AND BELTS ARE PROPERLY TENSIONED VERIFY THAT SCROLL COMPRESSOR IS ROTATING IN THE CORRECT DIRECTION VERIFY THAT CRANKCASE HEATER HAS BEEN ENERGIZED FOR 24 HOURSSTART-UPELECTRICALSUPPLY FAN AMPS EXHAUST FAN AMPSTEMPERATURESOUTDOOR-AIR TEMPERATURE F DB (Dry-Bulb)RETURN-AIR TEMPERATURE F DB F WB (Wet-Bulb)COOLING SUPPLY AIR FGAS HEAT SUPPLY AIR FPRESSURES VERIFY REFRIGERANT CHARGE USING CHARGING CHART ON PAGE 45.GENERAL ECONOMIZER MINIMUM VENT AND CHANGEOVER SETTINGS TO JOB REQUIREMENTSMODEL NO.: SERIAL NO.:DATE: TECHNICIAN:SUPPLY VOLTAGE L1-L2 L2-L3 L3-L1COMPRESSOR AMPS — COMPRESSOR NO. 1 L1 L2 L3— COMPRESSOR NO. 2 L1 L2 L3GAS INLET PRESSURE IN. WGGAS MANIFOLD PRESSURE STAGE NO. 1 IN. WG STAGE NO. 2 IN. WGREFRIGERANT SUCTION CIRCUIT NO. 1 PSIG CIRCUIT NO. 2 PSIGREFRIGERANT DISCHARGE CIRCUIT NO. 1 PSIG CIRCUIT NO. 2 PSIG

/ 60

Related manuals for Carrier 48TM016