Desa (V) CB36(N Owner's Operation And Installation Manual

14www.desatech.com117437-01HEARTH ACCESS AND ASSEMBLYRemoving Top Louver Trim PanelThe top louver panel may be removed for inspection and cleaningby following the instructions for removing the lower louver accesspanel. (see Figure 28).Removing Lower Louver Access Panel1. Use your index fingers to locate the left and right spring latchesfound just under the top louver then draw them inward to releasethe pins holding the panel on the side face (see Figure 28).2. Swing the louver panel out until it clears the fireplace opening.3. Pull the entire panel out until the bottom tabs are free of the slotopenings in the lower face frame.HEARTH ACCESS AND ASSEMBLYRemoving Lower Louver Access PanelRemoving Top Louver Trim PanelRemoving/Replacing Glass DoorFigure 28 -Removing Lower Louver Access PanelWARNING: If fireplace has been running, turn offand let cool before accessing or servicing the unit.WARNING: Handle glass door panel with care. Donot strike, slam, or otherwise abuse glass. Do notoperate fireplace with glass door removed, cracked,or broken.Removing/Replacing Glass DoorIf replacement of glass is necessary, the entire assembly, glass andframe, must be replaced. If glass is broken, wear gloves and tape theremaining fragments onto the frame.1. Placing a screw driver or your finger tips into the gap betweenthe lower glass panel rail and the bottom face frame, lift theglass door assembly until the door pins clear the locatingholes in the bottom face frame (see detail Figure 29).2. Swing bottom glass panel assembly out until the door pins onthe lower rail clears the bottom face frame (see Figure 30).3. Lower the door down until the upper door pins are free of thelocating holes in the spring clips and place in a safe area.4. Replace glass panel in reverse order by inserting the top doorpins into the spring clips, lifting up at the lower frame rail,and locating the bottom pins in the holes on the lower face frame.Figure 30 - Removing/Replacing Glass DoorSpring Latch3. PullOut Panel2. SwingOut PanelLocating SlotLower LouverAccess Panel1. Draw Latches InwardPanel TabSpring ClipsGlass PanelFrame Rail1. Lift Up Panelat Lower RailFigure 29 -Removing/Replacing Glass DoorLocatingHoleDoor PinGlass PanelFrame Rail2. Swing OutPanel3. LowerPanel Out