NightStick XPP-5460GX Instruction Manual

NightStick XPP-5460GX Instruction Manual Manual pdf 1 page image

Bayco Products, Inc. • 640 South Sanden Blvd. • Wylie, TX 75098 • USA • 1-800-233-2155 • 1-469-326-9400 • www.nightstick.comINS-XPP-5460GX-17 07-26-2018Instruction ManualXPP-5460GXUS PATENT 9,713,217Please read these instructions before using this product. They includeimportant safety and operation information.THE XPP-5460GX IS APPROVED FOR USECLASS I DIV 1 GRPS A-D T4CLASS II & III DIV 1 GRPS E-GCLASS I ZONE 0 GRP IIC T4CLASS II ZONE 20 IIIC T135ºCEx ia IIC T4 GaDEMKO 17 ATEX 1824IECEx UL 17.0003-20ºC ≤ Tamb ≤ +40ºC1.5V/Cell / E92 or EN920359E 467756INTRINSICALLY SAFESECURITE INTRINSEQUEII 1 G Ex ia IIC T4 GaBayco Products, Inc. XPP-5460WARNINGS:Replace batteries in a non-hazardous location.Use only Energizer Model E92 or EN92 batteries.AVERTISSEMENT:Remplacer les piles dans une zone non dangereuse.Utiliser uniquement les piles Energizer AAA - modèle E92 ou EN92.Ex ia FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONSWylie, TX 75098ID 4003544WARNINGS - INTRINSICALLY SAFEy Warning: Use only the approved non-rechargeable batteries listed below.y Warning: Do NOT attempt to use rechargeable AAA batteries with this light.y Warning: To prevent ignition of a hazardous atmosphere, do not open thebattery compartment in the hazardous environment. This task must ONLY beperformed in an area known to be non-hazardous.y Warning: When exchanging batteries, use only ENERGIZER E92 or EN92BATTERIES.y Warning: To prevent ignition of a hazardous atmosphere, the AAA batteriesmust only be exchanged in an area known to be non-hazardous.y Warning: To reduce the risk of explosion, do not mix new non-rechargeablebatteries with used non-rechargeable batteries, or mix non-rechargeablebatteries from different manufacturers.y Warning: Substitution of components may impair intrinsic safety.SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETYy For personal safety, always confirm the rating of any known hazardous orpotentially hazardous location where the light is to be used.BATTERY INSTALLATIONWARNING: In order to maintain the XPP-5460GX’s Intrinsically Safe rating,the only AAA batteries certified for use with this light are the ENERGIZERE92 or EN92 BATTERIES.y Do not attempt to use any other brand or model of AAA batteries with this light.y Do not attempt to use any type of rechargeable AAA batteries with this light.Warning: To prevent ignition of a hazardous atmosphere, do not open thebattery compartment door in the hazardo us environment. This task mustONLY be done in an area known to be non-hazardous.y Loosen the locking screw located on the back of the battery compartment door.NOTE: Do NOT attempt to completely remove the locking screw. Doing so is notnecessary and may damage the threads. The screw simply needs to be loosenedenough to allow the battery compartment door to open.y Using 3 – AAA ENERGIZER E92 or EN92 BATTERIES (make sure that all3 batteries are of the same model), install the batteries in the back of the lightpaying close attention to the markings inside the battery compartment for properbattery terminal polarity alignment.y Close the battery compartment door.y Tighten locking screw. CAUTION: Do NOT over-tighten. Doing so may damagethe threads and impact the light’s Intrinsic Safety.OPERATIONTwo switches on the front of the headlamp control all functions.SPOTLIGHT SWITCHy First Press = spotlight high-brightnessy Second Press = spotlight low-brightnessy Third Press = offFLOODLIGHT SWITCHy First Press = floodlight high-brightnessy Second Press = floodlight low-brightnessy Third Press = offDUAL-LIGHT MODEy Press each switch one time to turn on both lights in high-brightness mode.y To shut down Dual-Light mode, press each switch two more times until eachlight turns off.WARRANTYLIMITED LIFETIME WARRANTYBayco Products, Inc. warrants this product to be free from defects in workmanshipand materials for the original purchaser’s lifetime. The Limited Lifetime Warrantyincludes the LEDs, housing and lenses. Rechargeable batteries, chargers, switches,electronics and included accessories are warranted for a period of two years withproof of purchase. Normal wear and failures which are caused by accidents, misuse,abuse, faulty installation and lightning damage are excluded.We will repair or replace this product should we determine it to be defective.This is the only warranty, expressed or implied, including any warranty ofmerchantability or fitness for a particular purpose.For a complete copy of the warranty, go to www.nightstick.com/nightstick-product-support/warranties. Retain your receipt for proof of purchase.