NightStick XPP-5450G Instruction Manual

Also see for XPP-5450G: Operating instructions

NightStick XPP-5450G Instruction Manual Manual pdf 1 page image

Bayco Products, Inc. • 640 South Sanden Blvd. • Wylie, TX 75098 • 1-800-233-2155 • 1-469-326-9400 • www.nightstick.comINS-XPP5450G-MH-19 02-21-2019Instruction ManualXPP-5450GPlease read these instructions before using your Nightstick XPP-5450GIntrinsically Safe Headlamp. They include important safety information andoperating instructions.THE XPP-5450G IS APPROVED FOR USECLASS I DIV 1 GRPS A-D T3CLASS II & III GRPS E-G T135CCLASS I ZONE 0 AEx ia IIC T3 GaCLASS I ZONE 0 Ex ia IIC T3 GaII 1 G Ex ia op is IIC T3 GaEx ia op is IIC T3 GaIntertek ITS 13 ATEX27854XIECEx ITS 17.0002X-20ºC ≤ Tamb ≤ +40ºC1.5V/Cell AAA Alkaline0359ID 4001184INTRINSICALLY SAFESECURITE INTRINSEQUEBayco Products, Inc. XPP-5450GWylie, TX 75098640 S. Sanden Blvd.INMETROSegurançaNCCEx ia op is IIC T3 Ga(-20ºC ≤ Tamb ≤ +40ºC)15.0330 XWARNINGS - INTRINSICALLY SAFEy Warning: Use only the approved non-rechargeable batteries listed below.y Warning: Do NOT attempt to use rechargeable AAA batteries with this light.y Warning: To prevent ignition of a hazardous atmosphere, do not open thebattery compartment in the hazardous environment. This task must ONLYbe performed in an area known to be non-hazardous.y Warning: When exchanging batteries, use only ENERGIZER E92 or EN92BATTERIES.y Warning: To prevent ignition of a hazardous atmosphere, the AAA batteriesmust only be exchanged in an area known to be non-hazardous.y Warning: To reduce the risk of explosion, do not mix new non-rechargeablebatteries with used non-rechargeable batteries, or mix non-rechargeablebatteries from different manufacturers.y Warning: Substitution of components may impair intrinsic safety.SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETYy For personal safety, always confirm the rating of any known hazardous orpotentially hazardous location where the light is to be used.BATTERY INSTALLATIONWARNING: In order to maintain the XPP-5450G’s Intrinsically Saferating, the only AAA batteries certified for use with this light are theENERGIZER E92 or EN92 BATTERIES.y Do not attempt to use any other brand or model of AAA batteries with this light.y Do not attempt to use any type of rechargeable AAA batteries with this light.Warning: To prevent ignition of a hazardous atmosphere, do not open thebattery compartment door in the hazardous environment. This task mustONLY be done in an area known to be non-hazardous.y Loosen the locking screw located on the back of the battery compartmentdoor. NOTE: Do NOT attempt to completely remove the locking screw.Doing so is not necessary and may damage the threads. The screw simplyneeds to be loosened enough to allow the battery compartment door to open.y Using 3 – AAA ENERGIZER E92 or EN92 BATTERIES (make sure thatall 3 batteries are of the same model), install the batteries in the back of thelight paying close attention to the markings inside the battery compartmentfor proper battery terminal polarity alignment.y Close the battery compartment door.y Tighten locking screw. CAUTION: Do NOT over-tighten. Doing so maydamage the threads and impact the light’s Intrinsic Safety.OPERATIONTHE XPP-5450G HAS TWO SEPARATE LIGHTING MODES:HIGH-BRIGHTNESS SPOTLIGHT MODEPress the button on top of the light one time.LOW-BRIGHTNESS SPOTLIGHT MODEPress the button on top of the light two times. Pressing the button a thirdtime will turn the light off.THE XPP-5450G HAS A TILT ADJUSTMENT FEATURE:Simply adjust the tilt angle of the light to illuminate the desired area.THE XPP-5450G COMES WITH TWO DIFFERENT HEADBANDS:ELASTIC NON-SLIP HEADBANDUse this headband for wearing the headlamp directly on your head orwhile wearing a soft hat such as a ball cap. The non-slip feature will keep thelight positioned on the head even during vigorous movement.HEAVY-DUTY RUBBER HEADBANDUse the heavy-duty rubber headband on any hardhat. The tacky natureof the strap will keep the light attached even if the hat is dropped or used inwet conditions.WARRANTYLIMITED LIFETIME WARRANTYBayco Products, Inc. warrants this product to be free from defects inworkmanship and materials for the original purchaser’s lifetime. The LimitedLifetime Warranty includes the LEDs, housing and lenses. Rechargeablebatteries, chargers, switches, electronics and included accessories arewarranted for a period of two years with proof of purchase. Normal wear andfailures which are caused by accidents, misuse, abuse, faulty installation andlightning damage are excluded.We will repair or replace this product should we determine it to bedefective. This is the only warranty, expressed or implied, including anywarranty of merchantability or fitness for a particular purpose.For a complete copy of the warranty, go to www.nightstick.com/nightstick-product-support/warranties. Retain your receipt for proof of purchase.