NightStick XPP-5452G Instruction Manual

Also see for XPP-5452G: Operating instructions Instruction manual

NightStick XPP-5452G Instruction Manual Manual pdf 1 page image

Bayco Products, Inc. • 640 South Sanden Blvd. • Wylie, TX 75098 • 1-800-233-2155 • 1-469-326-9400 • www.mynightstick.comINS-XPP5452G-15Nightstick 5452 HeadlampCLASS I DIV 1 GRPS A-D T3CLASS II & III GRPS E-G T135CCLASS I ZONE 0 AEx ia IIC T3 GaCLASS I ZONE 0 Ex ia IIC T3 GaII 1 G Ex ia IIC T3 GaEx ia IIC T3 GaIntertek ITS 13 ATEX27854XIECEx ETL 13.0031X&7DPE&1.5V/Cell AAA Alkaline0359ID 4001184INTRINSICALLY SAFESECURITE INTRINSEQUEConforms to:ANSI/UL STD 913, ANSI/UL60079-0, ANSI/UL 60079-11ANSI/ISA 60079-26Certified to:CAN/CSA STD C22.2 No 157CAN/CSA STD C22.2 No 60079-0CAN/CSA STD C22.2 No 60079-11CSA STD C22.2 No 25Instruction ManualXPP-5452GTHANK YOU FOR SELECTING THE NIGHTSTICK XPP-5452GINTRINSICALLY SAFE HEADLAMP!PLEASE SAVE THESE INSTRUCTIONSPlease read these instructions before using your Nightstick XPP-5452GIntrinsically Safe Headlamp. They include important safety information andoperating instructions.THE XPP-5452G IS APPROVED FOR USEWARNINGS - INTRINSICALLY SAFE Warning: Use only the approved non-rechargeable batteries listed below. Warning: Do NOT attempt to use rechargeable AAA batteries with thislight. Warning: To prevent ignition of a hazardous atmosphere, do not open thebattery compartment in the hazardous environment. This task must ONLYbe performed in an area known to be non-hazardous. Warning: When exchanging batteries, use only ENERGIZER E92 or EN92BATTERIES. Warning: To prevent ignition of a hazardous atmosphere, the AAA batteriesmust only be exchanged in an area known to be non-hazardous. Warning: To reduce the risk of explosion, do not mix new non-rechargeablebatteries with used non-rechargeable batteries, or mix non-rechargeablebatteries from different manufacturers. Warning: Substitution of components may impair intrinsic safety.SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY For personal safety, always confirm the rating of any known hazardous orpotentially hazardous location where the light is to be used.BATTERY INSTALLATIONWARNING: In order to maintain the XPP-5452G’s Intrinsically Saferating, the only AAA batteries certified for use with this light are theENERGIZER E92 or EN92 BATTERIES. Do not attempt to use any other brand or model of AAA batteries with thislight. Do not attempt to use any type of rechargeable AAA batteries with thislight.Warning: To prevent ignition of a hazardous atmosphere, do not openthe battery compartment door in the hazardous environment. This taskmust ONLY be done in an area known to be non-hazardous. Loosen the locking screw located on the back of the battery compartmentdoor. NOTE: Do NOT attempt to completely remove the locking screw.Doing so is not necessary and may damage the threads. The screw simplyneeds to be loosened enough to allow the battery compartment door toopen. Using 3 – AAA ENERGIZER E92 or EN92 BATTERIES (make sure thatall 3 batteries are of the same model), install the batteries in the back of thelight paying close attention to the markings inside the battery compartmentfor proper battery terminal polarity alignment. Close the battery compartment door. Tighten locking screw. CAUTION: Do NOT over-tighten. Doing so maydamage the threads and impact the light’s Intrinsic Safety.OPERATIONTHE XPP-5452G HAS TWO SEPARATE LIGHTING MODES: High-brightness Spotlight Low-brightness SpotlightHIGH-BRIGHTNESS SPOTLIGHT MODEPress the button on top of the light one time.LOW-BRIGHTNESS SPOTLIGHT MODEPress the button on top of the light two times. Pressing the button a thirdtime will turn the light off.THE XPP-5452G HAS A TILT ADJUSTMENT FEATURE:Simply adjust the tilt angle of the light to illuminate the desired area.THE XPP-5452G COMES WITH TWO DIFFERENT HEADBANDS:ELASTIC NON-SLIP HEADBANDUse this headband for wearing the headlamp directly on your head orwhile wearing a soft hat such as a ball cap. The non-slip feature will keep thelight positioned on the head even during vigorous movement.HEAVY-DUTY RUBBER HEADBANDUse the heavy-duty rubber headband on any hardhat. The tacky natureof the strap will keep the light attached even if the hat is dropped or used inwet conditions.

/ 4

Related manuals for NightStick XPP-5452G