W415-0910 / A / 09.16.1051NOTEThe control of the "Add On" style installation is the same as the fore mentioned paragraph except for theposition of the selector toggle switch being redundant.BOTH OIL AND ELECTRIC FURNACES HAVE RESET CONTROLS AND PROCEDURES REQUIREDTO RESTART THE UNITS IF A FAULT HAS BEEN DETECTED AND UNITS LOCKED OUT. ONLY AQUALIFIED INSTALLER/SERVICE PERSON SHALL PERFORM THESE RESET PROCEDURES AS ACAUSE AND REPAIR MUST BE DETERMINED BEFORE THE UNIT CAN BE RESTARTED. FAILURE TOFOLLOW THIS STEP COULD RESULT IN PROPERTY DAMAGE, INJURY OR DEATH.SERVICE PERSONS CAN FIND TROUBLESHOOTING AND RESET PROCEDURE IN THE MANUALSACCOMPANYING BOTH THE ELECTRIC FURNACE AND OIL BURNER MODULES.8.3 CONTROL SYSTEM - SUMMER FAN○ A summer fan switch has been added to the main electric control box. This will provide low speed aircirculation during the summer time when the furnace is not being used. Depress rocker switch to “SummerFan” position, thw switch will light and the fan will run.ENSURE THE SUMMER SWITCH REMAINS IN THE "OFF" POSITION DURING THE HEATINGSEASON. FAILURE TO COMPLY WITH THIS WILL RESULT IN EXCESSIVE CHILLING OF THEEXHAUST PRODUCTS AS THEY PASS THROUGH THE EXCHANGER PIPES, THE FURNACE FLUEAND THE CHIMNEY SYSTEM. THIS CHILLING WILL RESULT IN THE CONDENSATION OF EXHAUSTPRODUCTS IN THE EXCHANGER AND CHIMNEY RESULTING IN CREOSOTE BUILD UP. THECREOSOTE BUILD UP WILL RESULT IN REDUCED EFFICIENCIES OF THE EXCHANGER TUBES ANDSUBSTANTIALLY INCREASES THE RISK OF A CHIMNEY FIRE.Expansion / contraction noises during heating up and cooling down cycles are normal and to be expected.8.4 OPERATING SOUNDS AND SMELLSWhen first installed, the furnace brick and metal are cold and must become hot before the appliance willfunction well. During the break-in period (the first 2 or 3 fires) create only small, hot fires using kindling; this willallow the firebrick to cure. Do not be alarmed if small hairline cracks develop in the firebrick. This is a normaloccurrence and does not pose a safety hazard. The paint may also smell a little for the first few fires as itcures and you may wish to open a door or window to alleviate the smell.There are many different ways to start a fire, review the hints and warnings in this section to ensure the fire isstarted properly.
