RBI Infinity Energy 2 Installation Instructions Manual

Contents

99.1 - Condensate disposal.......................................................................................................................................... 5610 - INSTALLATION - Electrical connections ...............................................................................5810.1 - Electrical connections: overview ...................................................................................................................... 5810.1.1 - Connecting the power supply cable ....................................................................................................................... 5910.1.2 - Room Thermostat wiring (IB Boiler only)................................................................................................................ 5910.1.3 - Installing the outdoor temperature sensor (IB Boiler only) ..................................................................................... 5910.1.4 - Connection to an analog Vcc input......................................................................................................................... 6010.1.5 - Connection to a MODBUS protocol........................................................................................................................ 6010.2 - Connecting the IB boiler to an indirect water heater ........................................................................................ 6110.2.1 Indirect water heater priority selection ...................................................................................................................... 6110.3 - Connecting the IW water heater to a storage tank ........................................................................................... 6110.4 - Connecting the heater in cascade.................................................................................................................... 6411 - INSTALLATION - Removing of an heater from a common venting system .......................6611.1 - Removing of a heater from a common venting system .................................................................................... 6612 - INSTALLATION - CATEGORY IV: Vent and combustion air .................................................6712.1 - CATEGORY IV: Positive pressure condensing ................................................................................................ 6712.2 - CATEGORY IV: Venting and air piping systems .............................................................................................. 6712.3 - Minimum / Maximum allowable combustion air and vent piping lengths.......................................................... 6912.4 - Install vent and combustion air piping .............................................................................................................. 6912.5 - Air inlet pipe materials: ..................................................................................................................................... 7112.5.1 - Sealing of PVC, CPVC or ABS air inlet pipe .......................................................................................................... 7112.6 - PVC/CPVC vent piping materials ..................................................................................................................... 7212.6.1 - Installing PVC/CPVC vent and air piping ............................................................................................................... 7212.6.2 - PVC/CPVC air intake connection ........................................................................................................................... 7312.6.3 - PVC/CPVC vent connection ................................................................................................................................... 7312.7 - Stainless steel vent piping materials ................................................................................................................ 7412.7.1 - Stainless steel air intake connection ...................................................................................................................... 7412.7.2 - Stainless steel vent connection .............................................................................................................................. 7512.8 - Polypropylene vent piping materials ................................................................................................................ 7612.8.1 - Polypropylene air intake connection....................................................................................................................... 7712.8.2 - Polypropylene vent connection .............................................................................................................................. 7712.9 - Single pipe vent (not sealed combustion) ........................................................................................................ 7812.9.1 - Determine location ................................................................................................................................................. 7912.10 - Sidewall termination - Two pipes .................................................................................................................... 8012.10.1 - Vent/air termination .............................................................................................................................................. 8012.10.2 - Determine location ............................................................................................................................................... 8012.10.3 - Prepare wall penetrations..................................................................................................................................... 8212.10.4 - Termination and fittings ........................................................................................................................................ 8212.10.5 - Multiple vent/air terminations................................................................................................................................ 8212.11 - Sidewall termination – Concentric vent .......................................................................................................... 8312.11.1 - Description and usage .......................................................................................................................................... 8312.11.2 - Sidewall termination installation ........................................................................................................................... 8312.11.3 - Multiventing sidewall terminations ........................................................................................................................ 8412.12 - Vertical termination - Two pipes ..................................................................................................................... 8512.12.1 - Determine location ............................................................................................................................................... 8512.12.2 - Prepare roof penetrations..................................................................................................................................... 8512.12.3 - Termination and fittings ........................................................................................................................................ 8512.12.4 - Multiple vent/air terminations................................................................................................................................ 8612.13 - Vertical termination – Concentric vent............................................................................................................ 8712.13.1 - Description and usage.......................................................................................................................................... 8712.13.2 - Determine location ............................................................................................................................................... 8712.13.3 - Vertical termination installation ............................................................................................................................. 8712.13.4 - Multiventing vertical terminations ......................................................................................................................... 8813 - INSTALLATION - CATEGORY II: Vent and combustion air ..................................................8913.1 - CAT II: Negative pressure condensing ............................................................................................................. 8913.2 - CAT II: Adapter and increaser .......................................................................................................................... 8913.3 - Condensing vent option: CATEGORY II:.......................................................................................................... 9014 - INSTALLATION - Gas supply .................................................................................................92TABLE OF CONTENTS