Waldorf RN8410G Installation And Operation Manual

Also see for RN8410G: Installation and operation manual Installation and operation manual

Waldorf RN8410G Installation And Operation Manual Manual pdf 12 page image

10InstallationNOTE: Gas pressure regulator provided with this appliance is convertible between Natural Gasand LPG as shown in ‘Gas Conversion Section’ in this manual.Ensure regulator is converted to correct gas type that appliance will operate on.Regulator outlet pressure is fixed ex-factory for gas type that regulator is converted to andit is NOT to be adjusted.Regulator connections are 3/ 4 " BSP female.Connection to the appliance is 3 / 4 " BSP male.(Refer to ‘Specifications’ section for gas supply location dimensions).NOTE: A Manual Isolation Valve must be fitted to the individual appliance supply line.4. Correctly locate appliance into its final operating position and using a spirit level, adjust legs so thatappliance is level and at correct height.5. Connect gas supply to appliance. A suitable joining compound which resists breakdown action ofLPG must be used on every gas line connection, unless compression fittings are used.6. Check all gas connections for leakages using soapy water or other gas detecting equipment.7. Check gas operating pressure is as shown in‘Specifications’ section.NOTE: Measure burner operating pressure at manifold testpoint with two burners operating at ‘Full’ setting.8. Verify operating pressure remains correct.Commissioning1. Before leaving a new installation;a. Check the following functions in accordance with operating instructions specified in ‘Operation’section of this manual. Lighting the Griddle. Light the Open Burners. (F - Flame Failure Option). Light the Open Burners. (PF - Pilot and Flame Failure Option). Check the Low Fire burner operation. Oven Pilot Ignition. Oven Main Burner / Thermostat. Turning the Oven to ‘Stand-By’ Mode. Oven ‘Shut Down’.b. Ensure operator has been instructed in areas of correct lighting, operation, and shutdownprocedure for appliance.2. This manual must be kept by owner for future reference, and a record ofDate of Purchase, Dateof Installation andSerial Number of Unit recorded and kept with this manual. (These detailscan be found on Rating Plate attached to bottom right hand corner of bottom sill. Referto ‘Gas Connection’ section).NOTE: If it is not possible to get appliance to operate correctly, shut off gas supply and contactsupplier of this appliance.Fig 2ManifoldPressure TestPointDO NOT USE A NAKED FLAME TO CHECK FOR GAS LEAKAGES.Warning