Wood Stone WS-FD-9660-L-IR-CL Installation And Operation Manual

279660 & 11260 Fire Deck Coal-Fired OvenInstallation and Operation ManualAn ongoing program of product improvement may require us to changespecifications without notice. FD-9660-CL, FD-11260-CL,Revised November 2015. Doc no: M0044.03info@woodstone-corp.com or visit woodstone-corp.comWood Stone Corporation1801 W. Bakerview Rd.Bellingham, WA 98226 USAToll Free 800.988.8103Tel 360.650.1111Fax 360.650.1166OVEN INTERIORWood Stone recommends the use of long-handled brushes for sweeping up surface debris that will accumulate on the floor of theoven during use� Use a natural fiber brush, always brushing away from the Radiant Burner well� For deeper cleaning, use a brassbristled brush� The oven floor can be then cleaned with a damp rag wrapped around the brush head�Wood Stone offers an assortment of oven brushes available through your dealer� Specification sheets may be viewed on the WoodStone website under Tools & Accessories�TAKE CARE NOT TO BRUSH DEBRIS INTO THE RADIANT FLAME BURNER.OVEN EXTERIOR (DOORWAY AND MANTLE)All exterior stainless steel surfaces should be cleaned as necessary using an approved mild detergent, hot water and a soft clothor sponge� Stubborn residues may be removed using a non-metallic scouring pad� When scouring stainless steel surfaces, scrubwith the grain of the metal to prevent scratching�DO NOT POUR OR SPRAY LIQUIDS ONTO THE OVEN DECK OR INTO THE OVEN INTERIOR AS THIS CAN DAMAGE THECERAMIC AND WILL VOID THE WARRANTY.IMPORTANT: DO NOT USE EXCESSIVE AMOUNTS OF LIQUID WHEN WIPING ON OR AROUND THE OVEN CONTROLBOX.IMPORTANT: EMPTY THE ASH CHUTE DAILY TO AVOID BLOCKING OR DAMAGING THE COAL BLOWER FAN� DAMAGECAUSED BY IMPROPER MAINTENANCE IS NOT COVERED BY THE OVEN WARRANTY.NOTE: COAL GRATES NEED TO BE REPLACED APPROXIMATELY EVERY 4–6 MONTHS.Coal grates are a consumable item—life will vary depending on oven temperature, hours of operation, fuel consumption, andproper use of the coal fan� It is expected that they will require replacement approximately every 4–6 months� Running the coal fanon its lowest setting overnight will help extend the life of the grates� Replacement grates are available from the factory�DAILY MAINTENANCE