Harman Stove Company P35i Owner's Manual

Harman Stove Company P35i Owner's Manual Manual pdf 29 page image

29Save These Instructions 3-90-775 Pellets or Corn/Pellet Mixture OnlyP35i Fireplace Insert10 Service & MaintenanceA. Shut-down ProcedureThe best way to shut down the appliance is to simplylet it run out of fuel, and shut down naturally as thetemperature cools. This method is highly recommend-ed for the end of season shut-down.To shut-down otherwise, turn the mode selector to"OFF' verify by ensuring that the Status light goes out.The shut-down protocol of the circuit board will safelyallow the fire to go out. All motors will stop when cool,and only the POWER light will remain lit. It is now safeto un-plug the electrical supply.B. Quick Reference Maintenance ChartCleaning or Inspection Frequency Daily Weekly Monthly YearlyArea beneath burn pot grate /Igniter After each ton of fuel burned OR XAsh removal Depending on fuel quality OR X XBurn pot grate surface Depending on fuel quality OR XCombustion blower / paddle fan After each ton of fuel burned OR XDistribution blowerMore frequently depending onsurroundings OR XDoor latch inspection Prior to heating season OR XFeeder body / Fines collection area Depending on fuel quality OR XFirebox / thorough cleaning After each ton of fuel burned OR XGlassWhen view of fire becomesobstructed OR XHeat exchanger After each ton of fuel burned OR XHopper Whenever adding fuel OR XVenting systemMore frequently depending onfuel quality and quantity OR XSoot- Formation and Need For Removal-When wood is burned, the products of combustioncombine with moisture to form a soot residue whichaccumulates on the flue lining. When ignited, thissoot makes an extremely hot fire. The entire ventingsystem should be inspected at least once every twomonths during the heating season to determine if asoot buildup has occurred. If soot has accumulated,it should be removed to reduce the risk of a chimneyfire.If you experience a chimney fire; Turn the controlto "Off". Keep appliance doors and hopper lid closedand latched. Notify the fire department. Do not oper-ate the appliance until the chimney and connectorhave been inspected and approved by a chimneyprofessional.CAUTION! shOCK AND smOKE hAZARD!Proper Shut-down procedure must be followed.• Smoke spillage may occur if shut-down is notcomplete• Risk of shock if appliance is not disconnected fromthe supply power prior to servicing.follow the detailed instructions found in this section for each point listed in the chart below.NOTICE: For recommendation purposes only - More frequent cleaning is necessary if heavy buildup isencountered at the recommended intervals, or if you see soot coming from the vent. failure to clean yourappliance on a regular basis will void the product warranty.