Harman Stove Company P35i Owner's Manual

Harman Stove Company P35i Owner's Manual Manual pdf 3 page image

3Save These Instructions 3-90-775 Pellets or Corn/Pellet Mixture OnlyP35i Fireplace InsertTABLE OF CONTENTSSection 1: Listing and Code ApprovalsA. Appliance Certifications......................4B. Mobile Home Approval.......................4C. Glass Specifications...........................4D. Electrical Rating ................................4E. BTU & Efficiency Specifications.........4Section 2: Special Warnings and NotesA. Carbon Monoxide Warnings &Considerations....................................5B. Other Safety Considerations .............5Section 3: Getting StartedA. Design, Installation & Location .........6B. Fire Safety..........................................6C. Component Locator .........................7D. Pre-Use Checklist..............................8Section 4: Dimensions & ClearancesA. Appliance Dimensions .......................9B. Clearances to Combustibles.............10C. Floor Protection ..............................10D. Minimum Fireplace OpeningRequirements .................................10E. Mantel Projections ...........................10F. Factory Built Fireplaces.....................11Section 5: Vent InformationA. Vent Termination Requirements ......12B. Avoiding Smoke and Odors..............13C. Venting Requirements / Restrictions 14D. Existing Fireplace Installation...........15E. Rear Venting.....................................16F. Zero Clearance Cabinet ..................16Section 6: Mobile Home - (US only)A. Mobile Home Installation .................17Section 7: Appliance Set-UpA. Outside Air Attachment ......................18B. Installing the Surround ......................19C. Routing the Power Cord ....................19D. Securing the Mounting Frame............20E. Attaching the Venting .........................20F. Installing the Body Into The Frame.....21G. Control Board Installation ...................21H. Room Sensor Installation ..................21I. Optional Log Kit .................................22J. Optional Trim Kit ................................22K. Service Rail Kit ..................................22Section 8: Operating InstructionsA. Fire Safety .........................................23B. Fuel & Fuel Storage ...........................23C. General Operating Information ..........24D. Before Your First Fire ........................26E. Draft Test Procedure .........................26F. Starting a Fire "Manual" .....................26G. Starting a Fire "Automatic" ................27H. Maintaining The Fire ..........................27I. Relaxation Mode ................................27J. Shut-Down Procedure ....................... 27Section 9: TroubleshootingTroubleshooting Chart..............................28Section 10: Service & MaintenanceA. Shut-Down Procedure .......................29B. Quick Reference Maintenance...........29C. General Maintenance Procedures .....30D. Motors and Components....................34Section 11: Reference MaterialsA. Wiring Diagram ..................................38B. Power Failure / Back-up ....................39C. Service Parts Listing...........................40D. Custom Surround Sizes......................44E. Warranty Policy ..................................45Safety Alert Key:• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.• CAUTION! Indicates a hazardous situation which, if not avoided could result in minor or moderate injury.• NOTICE: Indicates practices which may cause damage to the appliance or to property.